Pasteurized fluid milk shelf life is influenced by raw milk quality. The microbial count and somatic cell count (SCC) determine the load of heat-resistant enzymes in milk. Generally, high levels of psychrotrophic bacteria in raw milk are required to contribute sufficient quantities of heat-stable proteases and lipases to cause breakdown of protein and fat after pasteurization. Sanitation, refrigeration, and the addition of CO2 to milk are used to control both total and psychrotrophic bacteria count. It is not uncommon for total bacterial counts of raw milk to be < 10,000 cfu/mL. In the past, fluid milk processors have not focused much attention on milk SCC. Increased SCC is correlated with increased amounts of heat-stable protease (plasmin) and lipase (lipoprotein lipase) in milk. When starting with raw milk that has a low bacterial count, and in the absence of microbial growth in pasteurized milk, enzymes associated with high SCC will cause protein and fat degradation during refrigerated storage, and produce off-flavors. As the ability to kill, remove, or control microbial growth in pasteurized refrigerated milk continues to improve, the original milk SCC will be the factor limiting the time of refrigerated storage before development of an off-flavor in milk. Most healthy cows in a dairy herd have a milk SCC < 50,000 cell/mL. Bulk tank SCC > 200,000 cell/mL are usually due to the contribution of high SCC milk from a small number of cows in the herd. Technology to identify these cows and keep their milk out of the bulk tank could substantially increase the value of the remaining milk for use in fluid milk processing. To achieve a 60- to 90-d shelf life of refrigerated fluid milk, fluid processors and dairy farmers need to work together to structure economic incentives that allow farmers to produce milk with the SCC needed for extended refrigerated shelf life.

Staphylococcus aureus is recognized worldwide as one of the major agents of dairy cow intra-mammary infections. This microorganism can express a wide spectrum of pathogenic factors used to attach, colonize, invade and infect the host. The present study evaluated 120 isolates from eight different countries that were genotyped by RS-PCR and investigated for 26 different virulence factors to increase the knowledge on the circulating genetic lineages among the cow population with mastitis. New genotypes were observed for South African strains while for all the other countries new variants of existing genotypes were detected. For each country, a specific genotypic pattern was found. Among the virulence factors, fmtB, cna, clfA and leucocidins genes were the most frequent. The sea and sei genes were present in seven out of eight countries; seh showed high frequency in South American countries (Brazil, Colombia, Argentina), while sel was harboured especially in one Mediterranean country (Tunisia). The etb, seb and see genes were not detected in any of the isolates, while only two isolates were MRSA (Germany and Italy) confirming the low diffusion of methicillin resistance microorganism among bovine mastitis isolates. This work demonstrated the wide variety of S. aureus genotypes found in dairy cattle worldwide. This condition suggests that considering the region of interest might help to formulate strategies for reducing the infection spreading.

The general goal of this research was to provide fluid milk processors with data to enable them to estimate the economic benefits they might derive from longer fluid milk shelf-life or new marketing opportunities due to a reduction in raw milk SCC. The study objectives were: 1) to measure the time in days for pasteurized homogenized 2% milk to achieve a level of lipolysis and proteolysis caused by native milk enzymes present in milks of different somatic cell count (SCC) at 0.5 and 6 degrees C that would be sufficient to produce an off-flavor, 2) to determine whether milk fat content (i.e., 1, 2, and 3.25%) influences the level of proteolysis or lipolysis caused by native milk enzymes at 6 degrees C, and 3) to determine the time in days for milks containing 2% fat with different SCC to undergo sufficient lipolysis or proteolysis to produce an off-flavor due to the combination of the action of native milk enzymes and microbial growth at 0.5 and 6 degrees C. In experiment 1, pasteurized, homogenized milks, containing 2% fat were prepared from raw milk containing four different SCC levels from < 100,000 to > 1,000,000 cells/ml. Each of the four milks was stored at 0.5 and 6 degrees C for 61 d. In experiment 2, pasteurized, homogenized milks containing 1, 2, and 3.25% fat were prepared starting from two raw milks containing two different SCC levels, one < 100,000 and the other > 1,000,000 cells/ml. In experiment 3, pasteurized, homogenized 2% fat milks were prepared starting from raw milks containing two different SCC levels, one < 100,000 and the other > 1,000,000 cells/ml. For experiments 1 and 2, all milks were preserved with potassium dichromate to prevent microbial growth but to allow the activity of native milk proteases and lipases during storage. For experiment 3, one set of milk was preserved with potassium dichromate to prevent microbial growth but to allow the activity of native milk proteases and lipases, and a second set of milk was unpreserved during storage at 0.5 and 6 degrees C for 29 d. Based on previous work, an off-flavor due to proteolysis was detected by 50% of panelists when the decrease in casein as a percentage of true protein (CN/TP) was > 4.76%. Our data indicated (assuming 50% of consumers would detect an off-flavor when CN/TP decreases 5%) that pasteurized milk containing 2% fat would develop an off-flavor at a time long after 61 and at 54 d for the low SCC milk, and at about 54 and 19 d for the high SCC milk, at 0.5 and 6 degrees C, respectively. Previous research reported that 34% of panelists could detect an off-flavor in milk containing 2% fat due to lipolysis at a (free fatty acid) FFA concentration of 0.25 meq/kg of milk. Based on these results, it was estimated in the present study that 34% of panelists would detect an off-flavor in a 2% fat pasteurized milk with low SCC at a time long after 61 and just after 61 d at 0.5 and 6 degrees C, respectively, while for milk with high SCC, an off-flavor would be detected by 34% of panelists at slightly longer than 61 and 35 d at 0.5 and 6 degrees C, respectively. The combination of low SCC milk and low storage temperature when coupled with processing technology to produce very low initial bacteria count in fluid milk could produce fluid milk that will maintain flavor quality for more than 61 d of storage at temperatures < 6 degrees C.

Background: Gyr cows are well adapted to tropical conditions, resistant to some tropical diseases and have satisfactory milk production. However, Gyr dairy herds have a high prevalence of subclinical mastitis, which negatively affects their milk yield and composition. The objectives of this study were (i) to evaluate the effects of seasonality, mammary quarter location (rear x front), mastitis-causing pathogen species, and somatic cell count (SCC) on milk composition in Gyr cows with mammary quarters as the experimental units and (ii) to evaluate the effects of seasonality and somatic cell count (SCC) on milk composition in Gyr cows with cows as the experimental units. A total of 221 lactating Gyr cows from three commercial dairy farms were selected for this study. Individual foremilk quarter samples and composite milk samples were collected once a month over one year from all lactating cows for analysis of SCC, milk composition, and bacteriological culture. Results: Subclinical mastitis reduced lactose, nonfat solids and total solids content, but no difference was found in the protein and fat content between infected and uninfected quarters. Seasonality influenced milk composition both in mammary quarters and composite milk samples. Nevertheless, there was no effect of mammary quarter position on milk composition. Mastitis-causing pathogens affected protein, lactose, nonfat solids, and total solids content, but not milk fat content. Somatic cell count levels affected milk composition in both mammary quarters and composite samples of milk. Conclusions: Intramammary infections in Gyr cows alter milk composition; however, the degree of change depends on the mastitis-causing pathogen. Somatic cell count is negatively associated with reduced lactose and nonfat solids content in milk. Seasonality significantly affects milk composition, in which the concentration of lactose, fat, protein, nonfat solids and total solids differs between dry and wet seasons in Gyr cows.

Subclinical mastitis is a common and easily disseminated disease in dairy herds. Its routine diagnosis via bacterial culture and biochemical identification is a difficult and time-consuming process. In this work, we show that matrix-assisted laser desorption/ionization time-of-flight mass spectrometry (MALDI-TOF MS) allows bacterial identification with high confidence and speed (1 d for bacterial growth and analysis). With the use of MALDI-TOF MS, 33 bacterial culture isolates from milk of different dairy cows from several farms were analyzed, and the results were compared with those obtained by classical biochemical methods. This proof-of-concept case demonstrates the reliability of MALDI-TOF MS bacterial identification, and its increased selectivity as illustrated by the additional identification of coagulase-negative Staphylococcus species and mixed bacterial cultures. Matrix-assisted laser desorption-ionization mass spectrometry considerably accelerates the diagnosis of mastitis pathogens, especially in cases of subclinical mastitis. More immediate and efficient animal management strategies for mastitis and milk quality control in the dairy industry can therefore be applied.