The aim of the present study was to evaluate the effect of dietary free fatty acid (FFA) content and the degree of saturation on egg quality, yolk fatty acid (FA) profile, and yolk cholesterol content. For a 15-wk period, a total of 144 laying hens (19-wk-old) were randomly assigned to 8 treatments arranged in a 2 × 4 factorial design, with 2 sources of crude oil (soybean oil and palm oil) and 4 levels of FFA (10, 20, 30, and 45%). The dietary treatments were achieved by progressively substituting the original oils with equivalent amounts of their corresponding acid oils (soybean acid oil and palm fatty acid distillate, respectively). No differences in ADFI or egg mass were found. However, dietary FFA reduced egg production (linear, P < 0.05) and increased the feed conversion ratio (linear, P < 0.05). Higher levels of FFA in soybean diets resulted in higher egg weight with higher albumen and yolk weights (linear, P < 0.01). Palm diets presented higher yolk:albumen ratio than soybean diets (P < 0.001), but the effect of FFA did not follow a linear trend. Hens fed soybean diets laid eggs with higher Haugh units (HU) than palm diets (P < 0.001), although increasing the dietary FFA% reduced the HU values in both (linear, P < 0.001). Palm diets enhanced shell quality with greater resistance to breakage, and higher dry matter and ash content than soybean diets (P < 0.05). No differences in egg chemical composition and yolk cholesterol content were found (P > 0.05). The saturation degree had a significant effect on all the analyzed yolk FA (P < 0.001) except for arachidonic acid (C20:4 n-6), whereas increasing the FFA content did not affect to a great extent. These results show that varying dietary FFA level did not affect egg quality and yolk composition as much as the dietary fat source did, supporting the use of acid oils and fatty acid distillates as fat ingredients for feed.

Palm fatty acid distillate (PFAD) is a by-product of palm oil (P) refining. Its use in chicken diets is a way to reduce the cost of feed and the environmental impact. Its low unsaturated:saturated fatty acid ratio (UFA:SFA) and its high free fatty acid (FFA) level could be partially counteracted by its blending with soybean oil (S). The objective was to assess the effect of replacing S with different levels of PFAD on lipid-class content and fatty acid (FA) digestibility along the intestinal tract and in the excreta of 11 and 35-day-old broiler chickens. Five experimental diets were prepared by supplementing a basal diet with S (S6), PFAD (PA6), two blends of them (S4-PA2 and S2-PA4), or P (P6) at 6%. Replacing S with PFAD did not affect performance parameters (p > 0.05) but negatively affected feed AME, FA digestibility, and FFA intestinal content (p < 0.05), especially in starter chicks. Including PFAD delayed total FA (TFA) absorption (p < 0.05) at 11 days, but at 35 days it did not affect the TFA absorption rate. The use of PFAD blended with S, when FFA ≤ 30% and UFA:SFA ≥ 2.6, led to adequate energy utilization in broiler grower-finisher diets.

This study was conducted to evaluate the effects of dietary free fatty acid (FFA) content and degree of fat saturation on production performance, lipid and calcium digestibility, and intestinal function of laying hens. For a 15-week period, a total of 144 laying hens (19 weeks old) were randomly assigned to 8 dietary treatments, which were obtained by gradually replacing crude soybean oil with soybean acid oil (AO), or crude palm oil with palm fatty acid distillate (FAD). Thus, there were 4 soybean and 4 palm diets with 6% added fat varying in their FFA percentage (10%, 20%, 30%, and 45%), following a 2 × 4 factorial design. Each treatment included 6 replicates with 3 birds per replicate. Average daily feed intake and final body weight were significantly higher in palm diets (P < 0.001), while no differences were found in egg mass and feed conversion ratio. Higher levels of FFA in soybean diets resulted in lower egg production and higher egg weight (linear, P < 0.01). Regarding the degree of fat saturation, hens fed soybean diets presented higher digestibility of ether extract (EE), fatty acids, and calcium than palm diets (P < 0.001). The dietary FFA percentage negatively affected the digestibility of EE and calcium (P < 0.01), while having little effect on FA digestibility. There was a significant interaction in the AME; lower values were reported in soybean diets as the dietary FFA percentage increased (linear, P < 0.01), whereas palm diets remained unaffected. The experimental diets had little effect on gastrointestinal weight and length. However, the jejunum of soybean diets showed higher villus height and higher villus height-to-crypt depth ratio than palm diets (P < 0.05), and the dietary FFA percentage increased the crypt depth and decreased the villus height-to-crypt depth ratio (linear, P < 0.05). It was concluded that varying dietary FFA content did not affect fat utilization as much as the degree of saturation did, supporting the use of AO and FAD as alternative fat ingredients.

Behavioural and genetic evidence shows that the taste system is intimately related to the sensing of nutrients with consequences for poultry nutrition practices. A better understanding of how chickens may sense fat could provide the background for selecting feedstuffs used in poultry feeds. Acid oils have the potential to be economical and sustainable feedstuffs. These fat by-products from the edible oil refining industry possess a similar fatty acid composition to the crude oils but are richer in free fatty acids (FFA). An experiment was conducted to study the effect of FFA content and the unsaturated:saturated ratio (U:S) on dietary preferences in hens. Four fat sources were added to a basal diet at an inclusion rate of 6%, determining the experimental diets: soybean oil (SO; high U:S, 5% FFA); soybean acid oil (SA; high U:S, 50% FFA); palm oil (PO; low U:S, 5% FFA); and palm fatty acid distillate (PFAD; low U:S, 50% FFA). The experimental diets were offered in a series of double-choice tests to forty-eight Lohmann Brown laying hens housed individually in cages. Each hen was offered the ten potential binary combinations of the four diets including each diet compared to itself (referred to as four control double-choices). Feed intake was measured for two hours twice a day after one hour of fasting. Consumption was analysed as a standard preference index (% of test diet intake in comparison with the total intake). Preference values were compared to the random choice value of 50% using the Student’s t-test. None of the four control comparisons differ significantly from 50% (p > 0.05), indicating that the changes in preference values observed in the other binary comparisons were related to the dietary changes associated to fat ingredients. Hens showed a feed preference for palm oil added diets over soybean oil diets (p < 0.05), with PO and PFAD being equally preferred (p < 0.05). However, in this trial the hens demonstrated a preference for SO (low %FFA) when offered in choice with SA (high %FFA) (p < 0.05). These results suggest that the degree of saturation plays an important role in dietary fat preferences: hens prefer predominantly saturated oils even when these are rich in FFA. Furthermore, when presented with a choice between predominantly unsaturated oils, hens prefer feed with a low %FFA. In conclusion, %FFA and the U:S ratio affected feed preferences in hens. The use of oils with greater preference values may give rise to greater feed palatability, enhancing feed intake at critical stages.

This experiment studied the effect of broiler breeder nutritional strategies on uniformity, carcass traits, tibia parameters, and behavior during rearing and prebreeder periods (up to 22 wk of age). One-day-old pullets (n = 384) were randomly assigned to 4 treatments arranged as a 2 × 2 factorial, with 2 fiber levels (control vs. fibrous diet, 15% diluted in AMEn and nutrient content) and 2 vitamin C feed inclusions (0 vs. 200 mg/kg). At 6, 15, and 22 wk, blood sampling was carried out (4 birds/replicate) to determine serum alkaline phosphatase (ALP) levels, and behavior was observed by visual scan sampling. At 22 wk, carcass traits, tibia parameters, and intestinal morphology were assessed (2 birds/replicate), and tail- and wing-feather integrity of all birds were scored. Fibrous diet did not modify BW uniformity, mortality, or tibia growth when compared with control diet. Pullets fed the fibrous diet had lower tibia breaking strength, elastic modulus, and ash content values (P < 0.05). They also had lower ALP serum level at 6 and 22 wk (P < 0.05), their breast muscle was less developed (18.5 vs. 19.8%, P < 0.05), and their abdominal fat deposition was higher (1.14 vs. 0.87%, P < 0.05). At 15 and 22 wk, they performed, on average, 97% less grasping feather pecking and 45% less non-food object pecking behaviors, and their wing-feather score was lower (P < 0.05) at 22 wk. Tail- and wing-feather scores of the control treatments were reduced by vitamin C inclusion (tail: 0.30 vs. 1.15, P < 0.05; wing: 0.98 vs. 1.26, P < 0.05) at 22 wk. In conclusion, fibrous diet improves carcass traits (reduces breast muscle and increases abdominal fat deposition), deteriorates bone mineral deposition and thus skeletal strength, and reduces stereotypic behaviors, improving wing-feather integrity. Vitamin C inclusion improves tail- and wing-feather integrity of lower in feed allowance.

The effects of dietary inclusion of soybean-sunflower and olive pomace acid oils on growth, digestibility and flesh composition were studied in European seabass. Eight diets were fed for 100 days (101.37 ± 0.33 g initial weight, mean ± SD), differing in the added fat source (25% fish oil, 75% experimental oil): S (crude soybean oil), SA (soybean-sunflower acid oil), O (crude olive pomace oil) or OA (olive pomace acid oil); 3 blends: S-O, S-OA, SA-OA at a 1:1 ratio; and a diet containing only fish oil (F) as a control. Animals fed OA showed the worst performance among dietary treatments, with the lowest weight, specific growth ratio, average daily gain and the highest feed conversion ratio (p < 0.01). In contrast, other diets including acid oils did not impair performance. Acid oil diets did not affect the apparent digestibility of dry matter, crude protein or total fatty acids (p > 0.05), but a lower digestibility of lipids and saturated fatty acids was observed (p < 0.001). Flesh composition and fatty acid profile were not affected by the high dietary free FA content (p > 0.05). Hence the results suggest that the studied acid oils may potentially be used in fish diets although further studies are needed.