The aim of this study was to evaluate the feasibility of biodiesel production by transesterification of Jatropha oil with methanol, catalyzed by non-commercial sn-1,3-regioselective lipases. Using these lipases, fatty acid methyl esters (FAME) and monoacylglycerols are produced, avoiding the formation of glycerol as byproduct. Heterologous Rhizopus oryzae lipase (rROL) immobilized on different synthetic resins and Carica papaya lipase (rCPL) immobilized on Lewatit VP OC 1600 were tested. Reactions were performed at 30°C, with seven stepwise methanol additions. For all biocatalysts, 51-65% FAME (theoretical maximum=67%, w/w) was obtained after 4h transesterification. Stability tests were performed in 8 or 10 successive 4h-batches, either with or without rehydration of the biocatalyst between each two consecutive batches. Activity loss was much faster when biocatalysts were rehydrated. For rROL, half-life times varied from 16 to 579h. rROL on Lewatit VPOC 1600 was more stable than for rCPL on the same support.

Sanitization by pH adjustment of dairy and pig slurries was evaluated for potential use as organic fertilizer in horticulture. This requires absence of Salmonella in 25 g of slurry and less than 1000 Escherichi coli colony-forming unit per gram of fresh slurry (Regulation (EU) 2019/1009). Additives used in the alkalinization and acidification treatments, included hydroxide-salts and nitrogen-based reactants to increase slurry pH to a basic range (9.0–11.0) and concentrated H₂SO₄ to decrease slurry pH to an acidic range (5.5–3.5). While low-cost urea was unable to increase the slurry pH above 9.5, ammonia efficiently increased slurry pH to the targeted values (but enhanced the emissions risk), whereas the effect of Ca(OH)₂ was hindered by its low solubility. Slurry sanitization by alkalinization was achieved at a pH of 9.5 for both slurries, using similar quantities of KOH or NaOH. KOH was selected for further tests since it provides a plant macronutrient. Acidification with concentrated H₂SO₄ was able to achieve sanitization by lowering the pH to 5.0. After a 60-d storage experiment with raw and treated slurries, the level of E. coli was below the sanitization limit for all samples. Storage had no significant impact on slurry characteristics, except for ammonium-nitrogen content. Acidification treatment minimized ammonia losses.