Incidents involving the release of chemical agents can pose significant risks to public health. In such an event, emergency decontamination of affected casualties may need to be undertaken to reduce injury and possible loss of life. To ensure these methods are effective, human volunteer trials (HVTs) of decontamination protocols, using simulant contaminants, have been conducted. Simulants must be used to mimic the physicochemical properties of more harmful chemicals, while remaining non‐toxic at the dose applied. This review focuses on studies that employed chemical warfare agent simulants in decontamination contexts, to identify those simulants most suitable for use in HVTs of emergency decontamination. Twenty‐two simulants were identified, of which 17 were determined unsuitable for use in HVTs. The remaining simulants (n = 5) were further scrutinized for potential suitability according to toxicity, physicochemical properties and similarities to their equivalent toxic counterparts. Three suitable simulants, for use in HVTs were identified; methyl salicylate (simulant for sulphur mustard), diethyl malonate (simulant for soman) and malathion (simulant for VX or toxic industrial chemicals). All have been safely used in previous HVTs, and have a range of physicochemical properties that would allow useful inference to more toxic chemicals when employed in future studies of emergency decontamination systems.

Planning for major incidents involving the release of hazardous chemicals has been informed by a multi-disciplinary research agenda which has sought to inform all aspects of emergency response, but with a focus in recent years on mass casualty decontamination. In vitro and human volunteer studies have established the relative effectiveness of different decontamination protocols for a range of chemical agents. In parallel, a programme of research has focused on communicating with and managing large numbers of contaminated casualties at the scene of an incident. We present an accessible overview of the evidence underpinning current casualty decontamination strategies. We highlight where research outcomes can directly inform response planning, including the critical importance of beginning the decontamination process as soon as possible, the benefits of early removal of contaminated clothing, the evidence under-pinning dry and wet decontamination and how effective communication is essential to any decontamination response. We identify a range of priority areas for future research including establishing the significance of the ‘wash-in’ effect and developing effective strategies for the decontamination of hair. We also highlight several areas of future methodological development, such as the need for novel chemical simulants. Whilst considerable progress has been made towards incorporating research outcomes into operational policy and practice, we outline how this developing evidence-base might be used to inform future iterations of mass casualty decontamination guidance.

The UK Initial Operational Response (IOR) to chemical incidents includes improvised decontamination procedures, which use readily available materials to rapidly reduce risk to potentially exposed persons. A controlled, cross-over human volunteer study was conducted to investigate the effectiveness of improvised dry and wet decontamination procedures on skin, both alone, and in sequence. A simulant contaminant, methyl salicylate (MeS) in vegetable oil with a fluorophore was applied to three locations (shoulder, leg, arm). Participants then received no decontamination (control) or attempted to remove the simulant using one of three improvised protocols (dry decontamination; wet decontamination; combined dry and wet decontamination). Simulant remaining on the skin following decontamination was quantified using both Gas Chromatography Tandem Mass Spectrometry (GC-MSMS) for analysis of MeS and UV imaging to detect fluorophores. Additionally, urine samples were collected for 24 hours following application for analysis of MeS. Significantly less simulant was recovered from skin following each improvised decontamination protocol, compared to the no decontamination control. Further, combined dry and wet decontamination resulted in lower recovery of simulant when compared to either dry or wet decontamination alone. Irrespective of decontamination protocol, significantly more simulant remained on the shoulders compared to either the arms or legs, suggesting that improvised decontamination procedures are less effective for difficult to reach areas of the body. There was no effect of decontamination on excreted MeS in urine over 24 hours. Overall, findings indicate that improvised decontamination is an effective means of rapidly removing contaminants from skin, and combinations of improvised approaches can increase effectiveness in the early stages of decontamination and in the absence of specialist resources at an incident scene. However, the variable control and consistency of improvised decontamination techniques means that further intervention is likely to be needed, particularly for less accessible areas of the body.

Decontamination of skin by washing may increase dermal absorption, a phenomenon known as the wash-in effect. The wash-in effect is frequently discussed in studies investigating casualty decontamination where potentially life-saving interventions may enhance the dermal penetration of toxic chemicals, leading to an increase in incidence of morbidity and rates of mortality. However, the wash-in effect is seldom investigated within the context of mass casualty decontamination and real-life consequences are therefore poorly understood. This paper reviews the existing literature on the wash-in effect to highlight the proposed mechanisms for enhanced absorption and evaluate the wash-in effect within the context of mass casualty chemical decontamination.

Methyl salicylate has a long history of use as a chemical warfare agent simulant for volatile lipophilic compounds such as sulphur mustard. An improved isotope dilution GC-MS/MS method was developed, optimised and validated for the analysis of methyl salicylate in human skin and hair samples, for use in emergency decontamination volunteer studies. Following derivatisation, quantification was measured on a triple quadrupole mass spectrometer, set to EI mode and conducting multiple reaction monitoring of target ions. The mass transitions were 209 → 179 and 213 → 161 for quantitation of methyl salicylate and methyl salicylate D4, respectively whereas qualifier ion transitions used to verify identity were 209 → 169 and 213 → 89. The method achieved excellent coefficient of determination (R2 > 0.9968 to 0.9999) over the range of 0.5-5000 ng/ml and the LOD and LOQ were 0.05 ng/ml and 0.5 ng/ml. The method was further validated for accuracy (intra-day and inter-day average 100.28% to 102.03% and 99.48% to 102.33%, respectively) and precision (intra-day RSD 1.43% to 2.35%, inter-day RSD 1.91% to 2.97%) at three concentrations (25, 250 and 2500 ng/ml). The validated method was successfully used to identify methyl salicylate in samples of human skin generated during volunteer studies of emergency decontamination systems and in hair of staff conducting these studies.