(2008). Microemulsions as novel drug carriers: the formation, stability, applications and toxicity. Expert Opinion on Drug Delivery: Vol. 5, No. 1, pp. 119-135. doi: 10.1517/17425247.5.1.119

This study was designed to investigate the possible histological effects of different intranasal (IN) formulations of indomethacin (IND) on nasal mucosa in sheep. For this purpose, oil-in-water (O/W) emulsion (E) and solution (S) formulations including 3 mg/mL of IND were prepared. Penetration enhancers such as polyvinylpyrolidone (PVP), citric acid (CA) and sodium taurocholate (NaT) were added to emulsion (1%) at the final step into the formulations. First, the effect of penetration enhancers on permeation of IND was evaluated by in vitro permeation studies in which sheep nasal mucosa was used. According to the permeation studies PVP showed the highest enhancing effect on the permeation rate of IND from sheep nasal mucosa. Furthermore, the IND permeation from E containing PVP (1.624 ± 0.045 mg) was significantly higher than that obtained from E (0.234 ± 0.012 mg) (p < 0.05). For the histological studies, white Karaman sheep of approximately 20 ± 5 kg, aged 4 to 8 months were used. They were randomly divided into eight groups, each including three sheep. Five experimental groups received different formulations of IND emulsion without/ with penetration enhancers (E-PVP, E-CA, E-NaT, E) and IND solution (S), respectively. Parallel controls were composed of either untreated groups and were given blank emulsion or isotonic sodium chloride solution (0.31 mg/kg). 2 mL of each experimental formulation was applied to both nostrils of sheep, and 1/3 central and lower regions of the nose were dissected and prepared for light microscopy. Specimens stained with hematoxylin and eosin and Gomori's trichrome were examined by light microscopy. No signs of inflammation or erosion were noticed in the nasal mucosa of the control groups. Widened epithelial intercellular spaces were noticed in E-CA, E-NaT, and E-PVP groups as well with the E-PVP group showing the largest intraepithelial separations. E-CA and E-NaT groups showed significant decrease in the amount of goblet cells, while hypoplasia was considerably moderate in the E-PVP group. Finally, intranasal administration of IND emulsion with PVP may be considered as an alternative to intravenous and per oral administrations of IND to overcome their adverse effects.

The purpose of the current research was to prepare and evaluate the potential use of microemulsion-based hydrogel (MBH) formulations for dermal delivery of benzocaine (BZN). The pseudoternary-phase diagrams were constructed for various microemulsions composed of isopropyl myristate (IPM) as oil phase, Span 20, Tween 20, Tween 80, cremophor EL and cremophor RH40 as surfactants, ethanol as cosurfactant and distilled water as aqueous phase. Finally, concentration of BZN in microemulsions was 2% (w/w). The physicochemical properties, such as conductivity, viscosity, pH, droplet size, polydispersity index and zeta potential of microemulsions, were measured. Carbopol 940 was used to convert BZN-loaded microemulsions into gel form without affecting their structure. Furthermore, excised rat abdominal skin was used to compare permeation and penetration properties of BZN loaded M3 and M3BHs with BZN solution. According to ex vivo study results, BZN-loaded M3BH1 showed highest flux values and high release rate values, and furthermore, this gel formulation had low surfactant content. Finally, in order to learn the localization of formulations within the dermal penetration, formulations and BZN solution were labeled with red oil O and subjected to fluorescence observation. In conclusion, BZN-loaded MBHs could be offered as a promising strategy for dermal drug delivery.

The objective of this study was to prepare the microemulsion of methotrexate (M-MTX) for oral use and to investigate the suppressive effect of MTX-loaded microemulsion on MCF-7 human breast cancer cells. At the same time this effect of M-MTX was compared with those of a solution of the drug (Sol-MTX). Microemulsion was composed of soybean oil as oil phase, a mixture of Cremophore EL and Span 80 as surfactants, and isopropyl alcohol as co-surfactant, and 0.2 N NaOH as the aqueous phase. MTX was added into microemulsion at the last stage. We clearly demonstrated that M-MTX had a significant cytotoxic effect on breast cancer cell lines and the cytotoxic effect of M-MTX was significantly more than that of solutions (p < 0.05) and IC(50) value for M-MTX was 40 ng/mL. We also examined M-MTX and Sol-MTX on a model biological environmental model. For this purpose a gastrointestinal cell culture model, the Caco-2 cell line, was used to investigate the cytotoxic effects of the polymeric carrier and its effect on the cell monolayer integrity. The differences between the viability of cells for M-MTX and Sol-MTX were significantly different when applied to ANOVA according to 2 x 8 factorial randomized design (p:0.016; for alpha: 0.05, power : 0.695). According to the in vitro cytotoxicity studies, we concluded that when MTX was incorporated into the microemulsion (M-MTX), which is a new drug carrier system, it suppresses tumour cell growth on multiple tumor lines. These results indicate that M-MTX may exert a low cytotoxic effect on normal cells and may be effective as an antitumor agent that induces apoptosis.