Water and nutrient deficiencies in soil are becoming a serious threat to crop production. Therefore, usable water and nutrient recovery from wastewater, such as urine and grey water, should be considered. In this work, we showed the possibility of using grey water and urine after processing in an aerobic reactor with activated sludge in which the nitrification process takes place. The resulting liquid (nitrified urine and grey water, NUG) contains three potential factors that can adversely affect plant growth in a hydroponic system: anionic surfactants, nutrient deficits, and salinity. After dilution and supplementation with small amounts of macro- and micro-elements, NUG was suitable for cucumber cultivation. Plant growth on this modified medium (enriched nitrified urine and grey water, NUGE) was similar to that of plants cultivated on Hoagland solution (HS) and reference commercial fertilizer (RCF). The modified medium (NUGE) contained a significant amount of sodium (Na) ions. Therefore, typical effects of salt stress were observed in cucumber plants, including reduced chlorophyll levels, slightly weaker photosynthesis parameters, increased H₂O₂ levels, lipid peroxidation, ascorbate peroxidase (APX) activity, and proline content in the leaves. In addition, reduced protein levels were observed in plants treated with recycled medium. At the same time, lower nitrate content in tissues was found, which may have resulted from their intensive use by nitrate reductase (NR), the activity of which significantly increased. Although cucumber is a glycophyte, it grew very well in this recycled medium. Interestingly, salt stress and possibly anionic surfactants promoted flower formation, which in turn could positively affect plant yield.

This is the first study that identifies nitrogen loss and drier liquor parameters in a full scale sludge drying facility. Obtained data enabled proposing novel treatment based on deammonification process that allows not only nitrogen removal from drier liquor but also from gravity thickeners supernatant, the stream that is considered too cold for deammonification. The novel treatment approach is compared with nitrification/denitrification in activated sludge process in terms of greenhouse gas emissions. The nitrogen loss during drying was calculated based on two independent methods using full scale data from a long-term measurement campaign. According to results, 9.8-11.2% of nitrogen from dewatered sludge, or 4.9-5.5 g N/kg of TS, was vaporized during drying and then was captured through the purification of process air in drier liquor. Overall, over 40 tN/a from drier liquor and 77 tN/a from gravity thickeners supernatant is recirculated to the activated sludge process and results in the additional emission of 670 426 kg CO_2e/a when nitrification/denitrification is applied. That can be lowered by 398 858 kgCO_2e/a when the novel approach is considered.