Copper nanoparticles (Cu NPs) have great potential in electronics and biomedical fields because of their efficient thermodynamic and anti-microbial properties. However, their potential toxic effects and kinetic data following repeated exposure are still unclear. We evaluated the physicochemical properties of Cu NPs (25 nm) and copper microparticles (Cu MPs, 14–25 μm). Comparative in vivo toxicity of Cu NPs and Cu MPs was evaluated by conducting a 28-day repeated oral dose study at equivalent dose levels of 0, 100, 200, and 400 mg/kg/day (vehicle, 1 % hydroxypropyl methylcellulose). We determined Cu levels in the blood, tissues, urine, and feces by using inductively coupled plasma mass spectrometry. The solubility of Cu NPs and Cu MPs was 84.5 and 17.2 %, respectively, in an acidic milieu; however, they scarcely dissolved in vehicle or intestinal milieus. The specific surface area of Cu NPs and Cu MPs was determined to be 14.7 and 0.16 m2/g, respectively. Cu NPs exhibited a dose-dependent increase of Cu content in the blood and tested organs, with particularly high levels of Cu in the liver, kidney, and spleen. Only for liver and kidney increased Cu levels were found in Cu MPs-treated rats. Cu NPs caused a dose-related increase in Cu levels in urine, whereas Cu MPs did not affect the urine Cu levels. Extremely high levels of Cu were detected in the feces of Cu MPs-treated rats, whereas much lower levels were detected in the feces of Cu NPs-treated rats. A comparative in vivo toxicity study showed that Cu NPs caused damages to red blood cells, thymus, spleen, liver, and kidney at ≥200 mg/kg/days, but Cu MPs did not cause any adverse effects even at the highest dose. Overall, the in vivo repeated dose toxicity study of Cu NPs and Cu MPs demonstrated that large surface area and high solubility in physiological milieus could directly influence the toxicological responses and biodistribution of Cu particles when administered orally. Under these experimental conditions, the no-observed-adverse-effect levels of Cu NPs and Cu MPs were determined to be 100 and ≥400 mg/kg/day, respectively.

Despite widespread use and prospective biomedical applications of copper nanoparticles (Cu NPs), their biosafety issues and kinetics remain unclear. Thus, the aim of this study was to compare the detailed in vivo toxicity of Cu NPs and cupric ions (CuCl₂; Cu ions) after a single oral dose. We determined the physicochemical characteristics of Cu NPs, including morphology, hydrodynamic size, zeta potential, and dissolution in gastric (pH 1.5), vehicle (pH 6.5), and intestinal (pH 7.8) conditions. We also evaluated the kinetics of Cu following a single equivalent dose (500 mg/kg) of Cu NPs and Cu ions. Cu NPs had highest dissolution (84.5%) only in gastric conditions when compared with complete dissolution of Cu ions under various physiological milieus. Kinetic analysis revealed that highest Cu levels in blood and tested organs of Cu NP-treated rats were 15%–25% lower than that of Cu ions. Similar to the case of Cu ions, Cu levels in the tested organs (especially liver, kidney, and spleen) of Cu NP-treated rats increased significantly when compared with the vehicle control. However, delay in reaching the highest level and biopersistence of Cu were observed in the blood and tested organs of Cu NP-treated rats compared with Cu ions. Extremely high levels of Cu in feces indicated that unabsorbed Cu NPs or absorbed Cu ions were predominantly eliminated through liver/feces. Cu NPs exerted apparent toxicological effects at higher dose levels compared with Cu ions and showed sex-dependent differences in mortality, biochemistry, and histopathology. Liver, kidney, and spleen were the major organs affected by Cu NPs. Collectively, the toxicity and kinetics of Cu NPs are most likely influenced by the release of Cu dissociated from Cu NPs under physiological conditions.