Multiwalled carbon nanotubes (MWCNT) have a fibrous structure and physical properties similar to asbestos and have been shown to induce malignant mesothelioma of the peritoneum after injection into the scrotum or peritoneal cavity in rats and mice. For human cancer risk assessment, however, data after administration of MWCNT via the airway, the exposure route that is most relevant to humans, is required. The present study was undertaken to investigate the carcinogenicity of MWCNT‐N (NIKKISO) after administration to the rat lung. MWCNT‐N was fractionated by passing it through a sieve with a pore size of 25 μm. The average lengths of the MWCNT were 4.2 μm before filtration and 2.6 μm in the flow‐through fraction; the length of the retained MWCNT could not be determined. For the present study, 10‐week‐old F344/Crj male rats were divided into five groups: no treatment, vehicle control, MWCNT‐N before filtration, MWCNT‐N flow‐through and MWCNT‐N retained groups. Administration was by the trans‐tracheal intrapulmonary spraying (TIPS) method. Rats were administered a total of 1 mg/rat during the initial 2 weeks of the experiment and then observed up to 109 weeks. The incidences of malignant mesothelioma and lung tumors (bronchiolo‐alveolar adenomas and carcinomas) were 6/38 and 14/38, respectively, in the three groups administered MWCNT and 0/28 and 0/28, respectively, in the control groups. All malignant mesotheliomas were localized in the pericardial pleural cavity. The sieve fractions did not have a significant effect on tumor incidence. In conclusion, administration of MWCNT to the lung in the rat induces malignant mesothelioma and lung tumors.

Multi‐walled carbon nanotube‐7 (MWCNT‐7) fibers are biopersistent and have a structure similar to asbestos. MWCNT‐7 has been shown to induce malignant mesothelioma when administered by intrascrotal or intraperitoneal injection in rats and mice, and an inhalation study demonstrated that rats exposed to respirable MWCNT‐7 developed lung tumors. MWCNT‐N, which is similar to MWCNT‐7, was shown to induce both lung tumors and malignant mesothelioma in rats when administered by trans‐tracheal intrapulmonary spraying (TIPS). The present study was performed to investigate the carcinogenicity of MWCNT‐7 when administered by the TIPS method. Ten‐week‐old male F344/Crj rats were divided into 3 groups and administered 0.5 mL vehicle, 0.250 μg/mL MWCNT‐7 or 0.250 μg/mL crocidolite once a week for 12 weeks (total doses of 1.5 mg/rat) and then observed for up to 104 weeks. Rats in the MWCNT‐7 group began to die from pathologies associated with the development of malignant mesothelioma 35 weeks after the final TIPS administration. Overall, the incidence of malignant mesothelioma in the MWCNT‐7 group was significantly higher than in the vehicle or crocidolite groups.

Background: Malignant pleural mesothelioma (MPM) is a debilitating disease of the pleural cavity. It is primarily associated with previous inhalation of asbestos fibers. These fibers initiate an oxidant coupled inflammatory response. Repeated exposure to asbestos fibers results in a prolonged inflammatory response and cycles of tissue damage and repair. The inflammation-associated cycles of tissue damage and repair are intimately involved in the development of asbestos-associated cancers. Macrophages are a key component of asbestos-associated inflammation and play essential roles in the etiology of a variety of cancers. Macrophages are also a source of C-C motif chemokine ligand 2 (CCL2), and a variety of tumor-types express CCL2. High levels of CCL2 are present in the pleural effusions of mesothelioma patients, however, CCL2 has not been examined in the serum of mesothelioma patients. Methods: The present study was carried out with 50 MPM patients and 356 subjects who were possibly exposed to asbestos but did not have disease symptoms and 41 healthy volunteers without a history of exposure to asbestos. The levels of CCL2 in the serum of the study participants was determined using ELISA. Results: Levels of CCL2 were significantly elevated in the serum of patients with advanced MPM. Conclusions: Our findings are consistent with the premise that the CCL2/CCR2 axis and myeloid-derived cells play an important role in MPM and disease progression. Therapies are being developed that target CCL2/CCR2 and tumor resident myeloid cells, and clinical trials are being pursued that use these therapies as part of the treatment regimen. The results of trials with patients with a similar serum CCL2 pattern as MPM patients will have important implications for the treatment of MPM.

Very little is known about the in vivo toxicity of inhaled double-walled carbon nanotubes (DWCNTs). In the present study, we compared the pulmonary toxicity of DWCNT to MWCNT-7, a well-known multi-walled carbon nanotube. Rats were divided into six groups: untreated, vehicle, low-dose DWCNT, high-dose DWCNT, low-dose MWCNT-7, and high-dose MWCNT-7. The test materials were administered by intra-tracheal intra-pulmonary spraying (TIPS) every other day for 15 days: the low-dose and high-dose groups were administered final total doses of 0.25 and 0.50 mg/rat of the test material. The animals were sacrificed 1 and 6 weeks after the final TIPS administration. Six weeks after the final TIPS administration, rats administered MWCNT-7 had high levels of macrophage infiltration into the lung with dense alveolar wall fibrous thickening throughout the lung; significant elevation of lactate dehydrogenase activity, alkaline phosphatase activity, and total protein concentration in the bronchioalveolar lavage fluid; an increase in the pulmonary cell PCNA index; slightly elevated levels of 8-OHdG DNA adducts in lung tissue DNA; a small but significant increase in protein concentration in the pleural cavity lavage fluid and an increase in the visceral mesothelial cell PCNA index. None of these parameters was increased in rats administered DWCNT. The primary lesion in rats administered DWCNT was scattered formation of granulation tissue containing internalized DWCNT fibers. Our data indicate that DWCNT has lower pulmonary and pleural toxicity than MWCNT-7.

Potassium octatitanate (K₂O·8TiO₂, POT) fibers are used as an alternative to asbestos. Their shape and biopersistence suggest that they are possibly carcinogenic. However, inhalation studies have shown that respired POT fibers have little carcinogenic potential. We conducted a short-term study in which we administered POT fibers, and anatase and rutile titanium dioxide nanoparticles (a-nTiO₂, r-nTiO₂) to rats using intra-tracheal intra-pulmonary spraying (TIPS). We found that similarly to other materials, POT fibers were more toxic than non-fibrous nanoparticles of the same chemical composition, indicating that the titanium dioxide composition of POT fibers does not appear to account for their lack of carcinogenicity. The present report describes the results of the 3-week and 52-week interim killing of our current 2-year study of POT fibers, with MWCNT-7 as a positive control and r-nTiO2 as a non-fibrous titanium dioxide control. Male F344 rats were administered 0.5 ml vehicle, 62.5 µg/ml and 125 µg/ml r-nTiO₂ and POT fibers, and 125 µg/ml MWCNT-7 by TIPS every other day for 2 weeks (eight doses: total doses of 0.25 and 0.50 mg/rat). At 1 year, POT and MWCNT-7 fibers induced significant increases in alveolar macrophage number, granulation tissue in the lung, bronchiolo-alveolar cell hyperplasia and thickening of the alveolar wall, and pulmonary 8-OHdG levels. The 0.5 mg POT- and the MWCNT-7-treated groups also had increased visceral and parietal pleura thickness, increased mesothelial cell PCNA labeling indices, and a few areas of visceral mesothelial cell hyperplasia. In contrast, in the r-nTiO2-treated groups, none of the measured parameters were different from the controls.

Idiopathic pulmonary fibrosis (IPF) is a pathological condition wherein lung injury precipitates the deposition of scar tissue, ultimately leading to a decline in pulmonary function. Existing research indicates a notable exacerbation in the clinical prognosis of IPF patients following infection with COVID-19. This investigation employed bulk RNA-sequencing methodologies to describe the transcriptomic profiles of small airway cell cultures derived from IPF and post-COVID fibrosis patients. Differential gene expression analysis unveiled heightened activation of pathways associated with microtubule assembly and interferon signaling in IPF cell cultures. Conversely, post-COVID fibrosis cell cultures exhibited distinctive characteristics, including the upregulation of pathways linked to extracellular matrix remodeling, immune system response, and TGF-β1 signaling. Notably, BMP signaling levels were elevated in cell cultures derived from IPF patients compared to non-IPF control and post-COVID fibrosis samples. These findings underscore the molecular distinctions between IPF and post-COVID fibrosis, particularly in the context of signaling pathways associated with each condition. A better understanding of the underlying molecular mechanisms holds the promise of identifying potential therapeutic targets for future interventions in these diseases.