Background: The pyrolytic aqueous condensate (PAC) formed during the fast pyrolysis of wheat straw contains a variety of organic carbons and might therefore potentially serve as an inexpensive substrate for microbial growth. One of its main components is acetic acid, which was recently shown to be a suitable carbon source for the filamentous fungusAspergillus oryzae. However, the condensate also contains numerous toxic compounds that inhibit fungal growth and result in a tolerance of only about 1%. Therefore, to enable the use of the PAC as sole substrate forA. oryzaecultivations, a pretreatment seems to be necessary.Results: Various conditions for treatments with activated carbon, overliming, rotary evaporation and laccase were evaluated regarding fungal growth and the content of inhibitory model substances. Whereas the first three methods considerably increased the fungal tolerance to up to 1.625%, 12.5% and 30%, respectively, the enzymatic treatment did not result in any improvement. The optimum carbon load for the treatment with activated carbon was identified to be 10% (w/v) and overliming should ideally be performed at 100 °C and an initial pH of 12. The best detoxification results were achieved with rotary evaporation at 200 mbar as a complete removal of guaiacol and a strong reduction in the concentration of acetol, furfural, 2-cyclopenten-1-one and phenol by 84.9%, 95.4%, 97.7% and 86.2%, respectively, were observed.Subsequently, all possible combinations of the effective single methods were performed and rotary evaporation followed by overliming and activated carbon treatment proved to be most efficient as it enabled growth in 100% PAC shake-flask cultures and resulted in a maximum cell dry weight of 5.21 ± 0.46 g/L.Conclusion: This study provides a comprehensive insight into the detoxification efficiency of a variety of treatment methods at multiple conditions. It was revealed that with a suitable combination of these methods, PAC toxicity can be reduced to such an extent that growth on pure condensate is possible. This can be considered as a first important step towards a microbial valorization of the pyrolytic side-stream withA. oryzae.

Pyrolytic aqueous condensate (PAC) might serve as a cost-effective substrate for microbial malic acid production, as it is an unused side stream of the fast pyrolysis of lignocellulosic biomass that contains acetol and acetate as potential carbon sources. In the present study, shake flask cultures were performed to evaluate the suitability of acetol and its combination with acetate as substrates for growth and L-malate production with the filamentous fungus Aspergillus oryzae. Acetol concentrations of up to 40 g/L were shown to be utilized for fungal growth. In combination with acetate, co-metabolization of both substrates for biomass and malate formation was observed, although the maximum tolerated acetol concentration decreased to 20 g/L. Furthermore, malate production on PAC detoxified by a combination of rotary evaporation, overliming and activated carbon treatment was studied. In shake flasks, cultivation using 100% PAC resulted in the production of 3.37 ± 0.61 g/L malate, which was considerably improved by pH adjustment up to 9.77 ± 0.55 g/L. A successful scale-up to 0.5-L bioreactors was conducted, achieving comparable yields and productivities to the shake flask cultures. Accordingly, fungal malate production using PAC was successfully demonstrated, paving the way for a bio-based production of the acid.

The pyrolytic conversion of lignocellulosic biomass into fuels and chemicals is a promising option for the valorization of agricultural and forestry residues. However, technological developments are still needed to maximize product recovery and carbon fixation of the pyrolysis process. The pyrolysis aqueous condensate (PAC), a pyrolysis by-product, has a high water content and is highly toxic, hampering its use. The anaerobic digestion of PAC from different biomasses has been proven a viable technology for PAC valorization and detoxification, but its toxicity limits the methanogenic potential. Alternatively, methanation or VFA production from syngas by anaerobic mixed cultures are technologies of scientific interest. This study investigates the potential of a two-stage process to convert the carbon and energy in syngas and PAC into L-malate. PAC and syngas were co-fermented by two mixed cultures at 37 and 55 °C, identifying kinetic inhibitions and the effects of increasing PAC concentrations on the product pool. The media from selected mixed culture fermentations were then inoculated with Aspergillus oryzae for L-malate production. The results show that mixed cultures can perform simultaneous syngas fermentation and PAC detoxification. While PAC concentrations above 2% completely inhibited methanogenesis, CO consumption was inhibited at PAC concentrations above 5%, regardless of the temperature. In fermentations where PAC inhibited methanation, the mixed cultures channelled the carbon and electrons from syngas and PAC to volatile fatty acids or acetate/H₂ production, depending on the incubation temperature. Substantial detoxification of PAC was observed under PAC concentrations up to 10% independently of the rates of syngas metabolism. PAC detoxification enabled the further valorization of the acetate produced via syngas and PAC fermentations into L-malate, achieving yields up to 0.17 mM/mM. These results are promising for the development of an integrated process that simultaneously detoxifies and recovers value from gaseous and aqueous waste streams originating from pyrolysis.

Due to its acetate content, the pyrolytic aqueous condensate (PAC) formed during the fast pyrolysis of wheat straw could provide an inexpensive substrate for microbial fermentation. However, PAC also contains several inhibitors that make its detoxification inevitable. In our study, we examined the transcriptional response of Aspergillus oryzae to cultivation on 20% detoxified PAC, pure acetate and glucose using RNA-seq analysis. Functional enrichment analysis of 3463 significantly differentially expressed (log₂FC >2 & FDR < 0.05) genes revealed similar metabolic tendencies for both acetate and PAC, as upregulated genes in these cultures were mainly associated with ribosomes and RNA processing, whereas transmembrane transport was downregulated. Unsurprisingly, metabolic pathway analysis revealed that glycolysis/gluconeogenesis and starch and sucrose metabolism were upregulated for glucose, whereas glyoxylate and the tricarboxylic acid (TCA) cycle were important carbon utilization pathways for acetate and PAC, respectively. Moreover, genes involved in the biosynthesis of various amino acids such as arginine, serine, cysteine and tryptophan showed higher expression in the acetate-containing cultures. Direct comparison of the transcriptome profiles of acetate and PAC revealed that pyruvate metabolism was the only significantly different metabolic pathway and was overexpressed in the PAC cultures. Upregulated genes included those for methylglyoxal degradation and alcohol dehydrogenases, which thus represent potential targets for the further improvement of fungal PAC tolerance.