Lithium-ion batteries (LIBs) are dangerous to recycle, as they pose a fire hazard when cut and contain various chemical hazards. If recycled safely, LIBs provide a rich secondary source for metals such as lithium and cobalt, while reducing the environmental impact of end-of-life LIBs. Discharging the spent LIBs in a 5 wt.% NaCl electrolyte at room temperature enables their safe dismantling. A sludge was observed to form during the LIB discharging, with a composition of 34.9 wt.% Fe, 35 wt.% O, 17.7 wt.% Al, 6.2 wt.% C, and 4.2 wt.% Na. The average electrolytic solution composition after the first discharge cycle contained only 12.6 mg/L Fe, 4.5 mg/L Li, 2.5 mg/L Mn, and trace amounts of Ni and Co. Separating the active cathode powder from the aluminum cathode with a 10 wt.% NaOH leach produced an aqueous filtrate with an Al metal purity of 99.7%. The leach composition consisted of 9558 mg/L Al, 13 mg/L Li, 8.7 mg/L Co, and trace amounts of Mn and Ni. The hydrometallurgical sample preparation processes in this study enables the production of a pure black mass with less than 0.05 wt.% Co, 0.2 wt.% Li, 0.02 wt.% Mn, and 0.02 wt.% Ni losses from the active cathode material.

Rare earth elements (REEs) have been identified as valuable and critical raw materials, vital for numerous technologies and applications. With the increasing demand for and supply gap in REEs, many research studies have focused on alternative sources of REEs. This study involved an elemental and mineralogical characterisation of discarded coal from a coal plant and coal fly ash (CFA) from a power station in South Africa for REE presence. XRD results revealed that the discard coal sample consisted mainly of kaolinite, pyrite, siderite, quartz, calcite, gypsum, and muscovite, whereas CFA contained abundant glassy amorphous phases, alumina silicates, quartz, gypsum, calcite, and minute levels of muscovite and hematite. SEM-EDAX showed REE-carrying grains containing phosphorus in both discard coal and CFA samples. This was followed by investigating the leaching potential of REEs using hydrochloric acid from discard coal and CFA. This research’s potential impact is possibly providing a new and sustainable source of REEs. For that purpose, multiple batch leaching tests were performed to investigate the effects of temperature and acid concentration on the leaching efficiencies of REEs from discard coal and CFA. The experimental results indicated that temperature strongly influences REE leaching efficiency, while acid concentration has a lesser impact. This study identifies the best leaching conditions for the total REE recovery as 1 M HCl and 80 °C for discard coal and CFA.

A thermosiphon photobioreactor (TPBR) can potentially be used for biohydrogen production, circumventing the requirement for external mixing energy inputs. In this study, a TPBR is evaluated for photofermentative hydrogen production by Rhodopseudomonas palustris (R. palustris). Experiments were conducted in a TPBR, and response surface methodology (RSM), varying biomass concentration, and light intensity and temperature were employed to determine the operating conditions for the enhancement of both hydrogen production as well as biomass suspension. Biomass concentration was found to have had the most pronounced effect on both hydrogen production as well as biomass suspension. RSM models predicted maximum specific hydrogen production rates of 0.17 mol m⁻³h⁻¹ and 0.21 mmol g_CDW⁻¹h⁻¹ at R. palustris concentrations of 1.21 and 0.4 g L⁻¹, respectively. The experimentally measured hydrogen yield was in the range of 45 to 77% (±3.8%), and the glycerol consumption was 8 to 19% (±0.48). At a biomass concentration of 0.40 g L⁻¹, the highest percentage of biomass (72.3%), was predicted to remain in suspension in the TPBR. Collectively, the proposed novel photobioreactor was shown to produce hydrogen as well as passively circulate biomass.

Photofermentative hydrogen production has gained increasing attention as a source of green energy. To make such photofermentation processes economically competitive, operating costs need to be reduced, possibly through outdoor operation. Because photofermentation processes are light dependent, the emission spectrum and intensity of light both have a significant influence on the hydrogen production and merit investigation. This study investigates the effect of light sources on the hydrogen production and growth of Rhodopseudomonas palustris, comparing the organism’s productivity under longer-wavelength light and light mimicking sunlight. Hydrogen production is enhanced under longer-wavelength light, producing 26.8% (± 7.3%) more hydrogen as compared to under light mimicking that of sunlight; however, R. palustris is still able to produce a considerable volume of hydrogen under light with a spectrum mimicking that of sunlight, providing a promising avenue for future research.