Aeromonas hydrophila is a Gram-negative bacterium that causes high mortality in different fish species and at different growth stages. Although vaccination has significantly contributed to the decline of disease outbreaks in aquaculture, the use of oral vaccines has lagged behind the injectable vaccines due to lack of proven efficacy, that being from primary immunization or by use of boost protocols. In this study, the outer membrane protein W (OmpW) of A. hydrophila was cloned, purified, and encapsulated in poly d,l-lactide-co-glycolic acid (PLGA) nanoparticles (NPs) for oral vaccination of rohu (Labeo rohita Hamilton). The physical properties of PLGA NPs encapsulating the recombinant OmpW (rOmpW) was characterized as having a diameter of 370–375 nm, encapsulation efficiency of 53% and −19.3 mV zeta potential. In vitro release of rOmpW was estimated at 34% within 48 h of incubation in phosphate-buffered saline. To evaluate the efficacy of the NP-rOmpW oral vaccine, two antigen doses were orally administered in rohu with a high antigen (HiAg) dose that had twice the amount of antigens compared to the low antigen (LoAg) dose. Antibody levels obtained after vaccination showed an antigen dose dependency in which fish from the HiAg group had higher antibody levels than those from the LoAg group. The antibody levels corresponded with post challenge survival proportions (PCSPs) and relative percent survival (RPS) in which the HiAg group had a higher PCSP and RPS than the LoAg group. Likewise, the ability to inhibit A. hydrophila growth on trypticase soy agar (TSA) by sera obtained from the HiAg group was higher than that from the LoAg group. Overall, data presented here shows that OmpW orally administered using PLGA NPs is protective against A. hydrophila infection with the level of protective immunity induced by oral vaccination being antigen dose-dependent. Future studies should seek to optimize the antigen dose and duration of oral immunization in rohu in order to induce the highest protection in vaccinated fish.

The use of oral vaccination in finfish has lagged behind injectable vaccines for a long time as oral vaccines fall short of injection vaccines in conferring protective immunity. Biodegradable polymeric nanoparticles (NPs) have shown potential to serve as antigen delivery systems for oral vaccines. In this study the recombinant outer membrane protein A (rOmpA) of Edwardsiella tarda was encapsulated in chitosan NPs (NP-rOmpA) and used for oral vaccination of Labeo fimbriatus. The rOmpA purity was 85%, nanodiameter <500 nm, encapsulation efficiency 60.6%, zeta potential +19.05 mV, and there was an in vitro release of 49% of encapsulated antigen within 48 h post incubation in phosphate-buffered saline. Empty NPs and a non-formulated, inactivated whole cell E. tarda (IWC-ET) vaccine were used as controls. Post-vaccination antibody levels were significantly (p = 0.0458) higher in the NP-rOmpA vaccinated fish (Mean OD₄₅₀ = 2.430) than in fish vaccinated with inactivated whole cell E. tarda (IWC-ET) vaccine (Mean OD₄₅₀ = 1.735), which corresponded with post-challenge survival proportions (PCSP) of 73.3% and 48.28% for the NP-rOmpA and IWC-ET groups, respectively. Serum samples from NP-rOmpA-vaccinated fish had a higher inhibition rate for E. tarda growth on tryptic soy agar (TSA) than the IWC-ET group. There was no significant difference (p = 0.989) in PCSPs between fish vaccinated with empty NPs and the unvaccinated control fish, while serum from both groups showed no detectable antibodies against E. tarda. Overall, these data show that the NP-rOmpA vaccine produced higher antibody levels and had superior protection over the IWC-ET vaccine, showing that encapsulating OmpA in chitosan NPs confer improved protection against E. tarda mortality in L. fimbriatus. There is a need to elucidate the possible adjuvant effects of chitosan NPs and the immunological mechanisms of protective immunity induced by OMPs administered orally to fish.