Anthramycin (ANT) is a member of the pyrolobenzodiazepine family and is a potent cytotoxic agent. Previously, we reported the topical delivery of ANT from a range of solvents that may also act as skin penetration enhancers (SPEs). The skin penetration and uptake was monitored for simple solutions of ANT in propylene glycol (PG), dipropylene glycol (DiPG), Transcutol P (TC), isopropyl myristate (IPM), propylene glycol monocaprylate (PGMC) and propylene glycol monolaurate (PGML). The amounts of PG, DiPG and TC that were taken up by, and that penetrated the skin were also measured, with a clear dependence of ANT penetration on the rate and extent of PG and TC permeation. The present work investigates ANT skin delivery from a range of binary and ternary systems to determine any potential improvement in skin uptake compared with earlier results for the neat solvents. Following miscibility and stability studies a total of eight formulations were taken forward for evaluation in human skin in vitro. Binary systems of PG and water did not result in any skin permeation of ANT. Combining PG with either PGMC or PGML did promote skin penetration of ANT but no significant improvement was evident compared with PG alone. More complex ternary systems based on PG, DiPG, PGMC, PGML and water also did not show significant improvements on ANT permeation, compared with single solvents. Total skin penetration and retention of ANT ranged from 1 to 6% across all formulations studied. Where ANT was delivered to the receptor phase there were also high amounts of PG permeation with >50% and ~35% PG present for the binary systems and ternary vehicles, respectively. These findings along with our previous paper confirm PG as a suitable solvent / SPE for ANT either alone or in combination with PGML or PGMC. The results also underline the necessity for empirical testing to determine whether or not a vehicle is acting as a SPE for a specific active in a topical formulation.

Previously, we reported the use of confocal Raman spectroscopy (CRS) as a novel non-invasive approach to determine drug disposition in the skin in vivo. Results obtained by CRS were found to correlate with data from the well-established in vitro permeation test (IVPT) model using human epidermis. However, these studies used simple vehicles comprising single solvents and binary or ternary solvent mixtures; to date, the utility of CRS for monitoring dermal absorption following application of complex marketed formulations has not been examined. In the present work, skin delivery of diclofenac sodium (DFNa) from two topical dermatological drug products, namely Diclac^® Lipogel 10 mg/g and Primofenac^® Emulsion gel 1%, was determined by IVPT and in vivo by both CRS and tape stripping (TS) methodologies under similar experimental conditions. The in vivo data were evaluated against the in vitro findings, and a direct comparison between CRS and TS was performed. Results from all methodologies showed that Diclac promoted significantly greater DFNa delivery to the skin (p < 0.05). The cumulative amounts of DFNa which permeated at 24 h in vitro for Diclac (86.5 ± 9.4 µg/cm²) were 3.6-fold greater than the corresponding amounts found for Primofenac (24.4 ± 2.7 µg/cm²). Additionally, total skin uptake of DFNa in vivo, estimated by the area under the depth profiles curves (AUC), or the signal intensity of the drug detected in the upper stratum corneum (SC) (4 µm) ranged from 3.5 to 3.6-fold greater for Diclac than for Primofenac. The shape of the distribution profiles and the depth of DFNa penetration to the SC estimated by CRS and TS were similar for the two methods. However, TS data indicated a 4.7-fold greater efficacy of Diclac relative to Primofenac, with corresponding total amounts of drug penetrated, 94.1 ± 22.6 µg and 20.2 ± 7.0 µg. The findings demonstrate that CRS is a methodology that is capable of distinguishing skin delivery of DFNa from different formulations. The results support the use of this approach for non-invasive evaluation of topical products in vivo. Future studies will examine additional formulations with more complex compositions and will use a wider range of drugs with different physicochemical properties. The non-invasive nature of CRS coupled with the ability to monitor drug permeation in real time offer significant advantages for testing and development of topical dermatological products.