The objective was to test inherent cooking rate differences on tenderness values of boneless pork chops when exogenous factors known to influence cooking rate were controlled. Temperature and elapsed time were monitored during cooking for all chops. Cooking rate was calculated as the change in °C per minute of cooking time. Warner-Bratzler shear force (WBSF) was measured on chops cooked to either 63 °C or 71 °C. Slopes of regression lines and coefficients of determination between cooking rate and tenderness values for both degrees of doneness (DoD) were calculated. Shear force values decreased as cooking rate increased regardless of DoD (p ≤ 0.05), however changes in tenderness due to increased cooking rate were limited (β1 = −0.201 for 63 °C; β1 = −0.217 for 71 °C). Cooking rate only explained 3.2% and 5.4% of variability in WBSF of chops cooked to 63 °C and 71 °C, respectively. Cooking loss explained the most variability in WBSF regardless of DoD (partial R² = 0.09–0.12). When all factors were considered, a stepwise regression model explained 20% of WBSF variability of chops cooked to 63 °C and was moderately predictive of WBSF (model R² = 0.34) for chops cooked to 71 °C. Overall, cooking rate had minimal effect on pork chop tenderness.

It was hypothesized that hybrid rye may replace corn in diets for growing and finishing pigs without impacting growth performance, carcass characteristics, or meat quality. A total of 128 pigs (23.69 ± 2.51 kg) were allotted to four treatments with eight replicate pens per treatment. Phases 1 and 2 diets were fed for 35 d each and phase 3 diets were fed for 27 d. Within each phase, pigs were fed a control corn and soybean meal diet or a diet in which 33%, 66%, or 100% of the corn in the control diet was replaced with hybrid rye. Average daily gain (ADG) and average daily feed intake (ADFI) decreased (linear, P < 0.05) in phase 1 with increased dietary inclusion of hybrid rye. In phase 3, gain:feed (G:F) increased and then decreased (quadratic, P < 0.05) with more hybrid rye in the diet. Overall ADG, ADFI, and G:F did not differ among treatments. Diet did not impact most carcass traits, but loin (visual) and backfat (instrumental L*) color were paler (linear, P < 0.05) with greater inclusion of hybrid rye in the diet. Organ weights increased (linear, P < 0.05) with increased dietary hybrid rye. In conclusion, pigs fed hybrid rye consumed less feed in phase 1, resulting in reduced ADG, but growth performance for the entire growing-finishing period did not differ among treatments. Hybrid rye may replace all the corn in growing and finishing pig diets without diminishing growth performance or carcass quality, but feed intake may be reduced at high inclusion rates.

Feeding growing-finishing pigs supplemental fat is a common practice in the swine industry and can result in improved feed efficiency and reduced feed intake; however, dietary lipids also play a key role in determining pork composition. The objectives of the current study were to evaluate the effects of feeding graded levels of high oleic soybean oil (HOSO) on growth performance and carcass characteristics. A total of 288 pigs raised in two separate blocks (144 pigs each) were assigned to one of four diets containing either 25% dried distiller’s grains with solubles (DDGS), 2% high oleic soybean oil (HOSO2), 4% high oleic soybean oil (HOSO4), or 6% high oleic soybean oil (HOSO6). Pigs were housed 4 per pen and fed for 98 d using a 3-phase feeding system. Pigs were individually weighed and feed intake was recorded throughout the trial to calculate average daily feed intake (ADFI) and gain to feed ratio (G:F). A total of 144 pigs were transported to the University of Illinois Meat Science Laboratory and fabricated into primal and subprimal cuts to calculate carcass cutting yields. Differences in growth performance were observed, with pigs fed the DDGS treatment exhibiting greater (P ≤ 0.01) overall ADFI consuming 0.21, 0.18, and 0.28 kg/d more than HOSO2, HOSO4, and HOSO6 diets, respectively. Pigs fed the HOSO6 diet had greater (P ≤ 0.03) overall G:F than pigs fed DDGS and HOSO2 diets but did not differ (P = 0.12) from pigs fed HOSO4. Furthermore, differences in carcass traits were observed. Hot carcass weight was increased (P ≤ 0.03) in pigs fed the HOSO6 diet compared with pigs fed the DDGS and HOSO2 diets, while pigs fed HOSO4 did not differ (P > 0.05) from either extreme. Additionally, pigs fed HOSO4 and HOSO6 produced fatter (P ≤ 0.01) carcasses with reduced (P ≤ 0.01) standardized fat-free lean. Minimal differences were observed in primal weights expressed as a percentage of chilled side including bone-in Boston butt, trimmed loin, and trimmed ham with primal weights decreasing with increasing inclusion of dietary HOSO. Overall, pigs fed HOSO2 had reduced ADFI with similar backfat thickness and standardized fat-free lean compared with pigs fed the DDGS treatment. However, pigs fed HOSO 4% and 6% not only had improvements in ADFI and G:F but also had increased backfat thickness, which resulted in reductions in standardized fat-free lean and primal weights expressed as a percentage of chilled side weight. Feeding pigs supplemental fat to increase caloric density is a common practice in the swine industry and can result in improved feed efficiency. However, high oleic soybean oil (HOSO), a relatively new feed ingredient, has not been extensively researched in pig diets. HOSO differs from conventional soybean oil in that it contains an increased proportion of oleic acid, a monounsaturated fatty acid. Therefore, our goal was to investigate the use of HOSO in the diets of pigs in the weeks leading up to marketing. A total of 288 pigs were fed one of four diets that differed in their source of fat. One diet contained 25% dried distiller’s grains with solubles (DDGS), while the other three had graded levels of HOSO (2%, 4%, or 6%). Pigs were fed diets for the last 14 wk leading up to slaughter. Pigs fed the highest level of HOSO grew more efficiently and were heavier than those fed the diet containing DDGS. However, pigs fed 6% HOSO were also fatter and yielded a reduced percentage of boneless meat cuts than those fed DDGS.

Broilers are commonly exposed to coccidiosis infections, and the use of dietary strategies to reduce losses in growth performance has practical implications for the poultry industry. Methionine (Met) is typically the first limiting amino acid for broilers and is involved in metabolic and immunological pathways; however, literature is conflicting on how dietary Met requirements are affected by environmental stressors. Our objective was to assess how the Met requirement changes during coccidiosis based on results of growth performance, carcass traits, and health outcomes. Two trials were conducted using 780 male Ross 308 broiler chicks in floor pens randomly assigned to 1 of 12 experimental treatments. All birds received common starter (d 0-10) and finisher (d 24-35, Trial 2 only) diets, and only differed based on their assigned experimental grower diet (d 10-24). Trial 1 experimental grower diets ranged from 2.61 to 6.21 g/kg digestible Met. Trial 2 experimental grower diets were formulated to contain 15% below, at, or 15% above the Met requirement determined in Trial 1. Birds were exposed to a coccidiosis challenge on d 11, with blood and tissue collection (1 bird/pen) on d 18 and carcass processing on d 35 (2 birds/pen) in Trial 2. Data were analyzed using a 1- or 2-way ANOVA. A non-linear regression analysis was conducted in Trial 1 to determine the Met requirement of 4.32 g of digestible Met/kg of diet using BW gain. Coccidiosis infection reduced (P < 0.05) growth performance during the experimental grower and overall study periods in Trial 2. Increasing dietary Met from below requirement to meeting requirement during the grower period improved (P < 0.001) BW gain and feed conversion ratio (FCR), but this effect was only significant between treatments below and above the requirement for the overall study period. There was an interactive effect (P = 0.038) on FCR for the overall study period. These findings provide evidence that the Met requirement is likely increased during coccidiosis based on growth performance outcomes.

Feeding growing-finishing pigs supplemental fat is a common practice in the swine industry and can result in improved feed efficiency and reduced feed intake; however, dietary lipids also play a key role in determining pork quality. Objectives of the study were to evaluate the effects of feeding graded levels of high oleic soybean oil (HOSO) on loin and belly quality. A total of 288 pig raised in two separate blocks (144 pigs each) were assigned to one of four diets containing either 25% dried distiller’s grains with solubles (DDGS), 2% high oleic soybean oil (HOSO₂), 4% high oleic soybean oil (HOSO₄), or 6% high oleic soybean oil (HOSO₆). Following the conclusion of the feeding trial, 144 pigs were slaughtered at the University of Illinois Meat Science Laboratory. Following fabrication, loins were collected for the evaluation of fresh quality measurements and color stability. Belly quality and fatty acid composition were evaluated using skin-on natural fall bellies. There were no differences (P ≥ 0.11) in pH, visual color, lightness (L*), drip loss, or WBSF among dietary treatments. However, visual marbling was increased (P ≤ 0.01) in loin chops from pigs fed HOSO₄ and HOSO₆ treatments compared with chops from pigs fed the DDGS dietary treatment. Additionally, loin chops were more red (a*) (P ≤ 0.01) from pigs fed HOSO diets when compared with pigs fed DDGS. Extractable lipid was decreased (P ≤ 0.01) in fresh loin chops from pigs fed DDGS and HOSO₂ diets compared with pigs fed HOSO₆. There were no differences (P ≥ 0.75) in trained sensory tenderness, juiciness, or flavor for loin chops from pigs fed different dietary treatments. Pork fatty acid composition was altered by dietary HOSO inclusion, with pigs fed DDGS having (P ≤ 0.01) the greatest concentration of C16:0 and was decreased with increasing levels of HOSO inclusion. Inversely, the percentage of C18:1n-9 was least (P ≤ 0.01) in pigs fed DDGS and increased with increasing levels of HOSO inclusion. Pigs fed DDGS produced wider (P ≤ 0.03) and thinner (P ≤ 0.04) bellies with reduced flop distance compared with pigs fed HOSO diets. Overall, HOSO diets did not negatively affect fresh loin quality or sensory traits of loin chops. Furthermore, feeding HOSO to swine resulted in bellies containing greater percentages of oleic acid and reduced percentages of palmitic and linoleic acid. Feeding pigs supplemental fat to increase caloric density is a common practice in the swine industry. However, dietary fats are also a key determinant of pork fat composition and may influence product quality. High oleic soybean oil (HOSO), a relatively new feed ingredient, differs from conventional soybean oil in that it contains an increased proportion of oleic acid, a monounsaturated fatty acid. However, HOSO has not been extensively researched in pig diets. Therefore, our goal was to investigate the use of dietary HOSO on fresh belly and loin quality. A total of 144 pigs, fed one of four diets that differed in fat source, were slaughtered at the University of Illinois Meat Science Laboratory. One diet contained 25% dried distiller’s grains with solubles (DDGS), while the other three had graded levels of high oleic soybean oil (2%, 4%, or 6%). Pigs were fed diets for the last 14 weeks leading up to slaughter. Pigs fed HOSO produced thicker, firmer bellies and fat tissue containing a decreased proportion of polyunsaturated fatty acids compared with DDGS-fed pigs. Feeding HOSO had little impact on fresh loin quality and palatability compared with feeding an industry-reference diet containing DDGS.

Pork hot carcass weights (HCW) have been increasing 0.6 kg per year, and if they continue to increase at this rate, they are projected to reach an average weight of 118 kg by the year 2050. This projection in weight is a concern for pork packers and processors given the challenges in product quality from heavier carcasses of broiler chickens. However, previous work demonstrated that pork chops from heavier carcasses were more tender than those from lighter carcasses. Therefore, the objective was to determine the effects of pork hot carcass weights, ranging from 90 to 145 kg with an average of 119 kg, on slice shear force and sensory traits of Longissimus dorsi chops when cooked to 63 or 71 °C, and to assess if differences in chilling rate can explain differences in sensory traits. Carcasses were categorized retrospectively into fast, medium, or slow chilling-rates based on their chilling rate during the first 17 h postmortem. Loin chops cut from 95 boneless loins were cooked to either 63 or 71 °C and evaluated for slice shear force and trained sensory panel traits (tenderness, juiciness, and flavor) using two different research laboratories. Slopes of regression lines and coefficients of determination between HCW and sensory traits were calculated using the REG procedure in SAS and considered different from 0 at P ≤ 0.05. As hot carcass weight increased, chops became more tender as evidenced by a decrease in SSF (63 °C β = −0.0412, P = 0.01; 71 °C β = −0.1005, P < 0.001). Furthermore, HCW explained 25% (R² = 0.2536) of the variation in chilling rate during the first 5 h of chilling and 32% (R² = 0.3205) of the variation in chilling rate from 5 to 13 h postmortem. Slow- and medium-rate chilling carcasses were approximately 12 kg heavier (P < 0.05) than fast chilling carcasses. Slice shear force of chops cooked to 63 and 71 °C was reduced in slow and medium chilling compared with fast chilling carcasses. Carcass temperature at 5 h postmortem explained the greatest portion of variation (R² = 0.071) in slice shear force of chops cooked to 63 °C. These results suggest that carcasses tend to chill slower as weight increases, which resulted in slight improvements in sensory traits of boneless pork chops regardless of final degree of doneness cooking temperature. Pork carcass weights have increased year over year for at least the past 25 yr. The poultry industry has experienced similar increases in carcass weights in the recent past. The increases in broiler carcass weights have resulted in detrimental impacts on quality. Contrary to the poultry industry, increases in pork carcass weights have resulted in a general improvement in pork quality, including tenderness. The underlying cause of these improvements has not been explained. In the present study, chilling rate was associated with carcass weights, particularly during the first 5 h postmortem. In fact, carcass temperature measured in the Longissimus dorsi muscle at 5 h postmortem was the most predictive of instrumental tenderness values when boneless pork chops were cooked according to UDSA guidelines for whole-muscle pork products. The metabolic conversion of muscle to meat is most active during this initial chilling period. Therefore, chilling rate, which is associated with carcass weight, may be influencing the conversion of muscle to meat and provide some explanation as to why heavy carcasses result in more tender pork chops.