The worldwide pressure on water resources is aggravated by rapid industrialization, with the food industry, particularly sugar factories, being the foremost contributor. Sugarcane, a primary source of sugar production, requires vast amounts of water, over half of which is discharged as wastewater, often mixed with several byproducts. The discharge of untreated wastewater can have detrimental effects on the environment, making the treatment and reuse of effluents crucial. However, conventional treatment systems may not be adequate for sugarcane industry effluent treatment due to the high organic load and variable chemical and mineral pollution. It is essential to explore pollution-remediating technologies that can achieve a nexus (water, energy, and food) approach and contribute to sustainable development. Based on the extensive literature, membrane technologies such as the membrane bioreactor have shown promising results in treating sugarcane industry wastewater, producing treated water of higher quality, and the possibility of biogas recovery. The byproducts generated from this treatment can also be recovered and used in agriculture for food security. To date, membrane technologies have demonstrated successful results in treating industrial wastewater. This critical review aims to evaluate the performance of traditional and conventional processes in order to propose sustainable perspectives. It also serves to emphasize the need for further research on operating conditions related to membrane bioreactors for valuing sugarcane effluent, to establish it as a sustainable treatment system.

Wastewater management remains a major challenge in developing countries due to the lack of adequate infrastructure, making the need for economically viable and efficient technologies that can be sustained by emerging economies imperative. The upflow anaerobic sludge blanket (UASB) reactor represents an efficient and low-cost technology that produces by-products from which valuable resources can be recovered. This study assessed the energy recovery potential in the form of electricity from biogas and sludge by-products produced by a full-scale UASB reactor. Biogas production rate and composition were monitored to determine the biogas energy recovery potential. Dehydrated sludge from sludge drying beds was likewise quantified and characterised for its elemental composition, immediate composition, gross calorific value and net calorific value to estimate sludge energy recovery potential. The average daily biogas production was found to be 611 ± 275 Nm³/d, with 65% methane in the biogas output. Average sludge dry matter production was determined to be 358.24 TS kg/d. The net energy recovery potential was estimated to be 534.1 MWh/yr, 36% more than the yearly energy demand (392.7 MWh/yr) of the entire plant. Conservative energy recovery at a UASB-based municipal wastewater treatment facility could serve as a self-supply energy option to support its operations.

The use of faecal sludge (FS) in anaerobic digestion (AD) requires a perfect knowledge of their composition. Considered as a very heterogeneous material, the high variability of FS can disturb biodigesters’ functionality and impact biogas production. Unique in West Africa, Kossodo’s biogas plant in Ouagadougou receives sludge from septic tanks and pit latrines. To evaluate the quality of sludge discharged in this treatment plant and its ability for AD, a characterization of 130 FS trucks from several onsite sanitation facilities was carried out. Physico-chemicals, including heavy metals and microbiological parameters, were analyzed using standard protocols. A biochemical methane potential test was employed to evaluate biogas yield. Results showed that raw sludge averaged 1.12% total solids (TS), 54.74% volatile solids (VS), 9253 mg/L chemical oxygen demand (COD), and 1645 mg/L biochemical oxygen demand (BOD). Settled faecal sludge exhibited higher levels of total coliforms, E. coli, helminth eggs, and heavy metals. Heavy metal levels met AD standards defined by VDI 4630, with decreasing toxicity order: Zn > Mn > Cu > Cr > Ni > Pb > As ≥ Hg. The carbon-to-nitrogen (C/N) ratio was 6.7 ± 4.3, indicating unsuitability for AD. Sludge settling increased C/N ratio by 46%, which was still below optimal AD conditions (20–30). Methane yield of raw and settled FS averaged 61 ± 0.2 and 156 ± 3.2 NL CH₄/kg VS removed, respectively. Co-substrate addition could enhance the methanogenic yield of these sludges. This study provides a valuable database on the characteristics of FS, supporting sustainable recovery options.

The present paper investigates the occurrence, removal, and accumulation of protozoan cysts and helminth eggs in a large anaerobic pond treating municipal wastewater of Ouagadougou (Burkina Faso). With a hydraulic retention time of 6.5 days, the anaerobic pond achieved 100% removal of helminth eggs and protozoan cysts most of the time, except during the hot period. The average residual concentrations of helminth eggs and protozoan cysts in the effluent were respectively 0.45 eggs/L (minimum 0 and maximum 3), and 5.4 cysts/L (minimum 0 and maximum 26). Protozoan cysts accumulation in sludge averaged 1,613 cysts/g total solids. Ancylostoma duodenale, Ascaris lumbricoides and Hymenolepis nana were the main helminth species found in the sludge. After 7 years of operation, the sludge in the pond still contained a high level of viable helminth eggs evaluated at 42%.