Crude rice bran oils from different rice cultivars and extraction methods bear different contents of nutraceuticals. The health benefits of lowering cholesterol activity of rice bran oil being confirmed by many reports are partly attributed to non-nutrient nutraceuticals, especially γ-oryzanol, phytosterols, and policosanols. As the world has been facing the global warming crisis, green extraction technology is gaining attention from many sectors. The current study aims to compare the nutraceutical composition with respect to γ-oryzanol, phytosterol, and policosanol content as well as the antioxidant properties of crude rice bran oils extracted from white and red rice bran using three green technologies, comparing with conventional hexane extraction. The data show that the traditional solvent extraction gave the highest oil yield percentage (26%), but it was not significantly different from subcritical liquefied dimethyl ether extraction (24.6%). Subcritical liquefied dimethyl ether extraction gave higher oil yield than supercritical CO₂ extraction (15.5–16.2%). The crude rice bran oil extracted using subcritical liquefied dimethyl ether extraction produced the highest total phenolic contents and antioxidant activities. The highest γ-oryzanol content of the crude rice bran oil was found in oil extracted by conventional cold press (1370.43 mg/100 g). The γ-oryzanol content of the oil obtained via subcritical liquefied dimethyl ether extraction was high (1213.64 mg/100 g) compared with supercritical CO₂ extraction. The red rice bran yielded the crude rice bran oil with the highest total phytosterol content compared with the white bran, and the oil from red rice bran extracted with subcritical liquefied dimethyl ether generated the highest total phytosterol content (1784.17 mg/100 g). The highest policosanol content (274.40 mg/100 g) was also found in oil obtained via subcritical liquefied dimethyl ether extraction.

Extracting nutraceuticals with high value from bagasse, filter mud, and sugarcane leaves discarded as sugar mill by-products, is crucial for the development of a sustainable bio-economy. These by-products are important sources of policosanols and phytosterols, which have a cholesterol-lowering effect. This research focused on using a promising green technology, subcritical liquefied dimethyl ether extraction, with a low pressure of 0.8 MPa, to extract policosanols and phytosterols and on application of pretreatments to increase their contents. For direct extraction by subcritical liquefied dimethyl ether without sample pretreatment, the highest extraction yield (7.4%) and policosanol content were found in sugarcane leaves at 2888 mg/100 g, while the highest and lowest phytosterol contents were found in filter mud at 20,878.75 mg/100 g and sugarcane leaves at 10,147.75 mg/100 g, respectively. Pretreatment of filter mud by ultrasonication in hexane solution together with transesterification before the second subcritical liquefied dimethyl ether extraction successfully increased the policosanol content, with an extract purity of 60%, but failed to increase the phytosterol content.

Musa (ABB group) “Kluai Namwa” bananas (Musa sp.) are widely grown throughout Thailand. Mali Ong is the most popular Kluai Namwa variety used as raw material for sun-dried banana production, especially in the Bangkratum District, Phitsanulok, Thailand. The sun-dried banana product made from Nanwa Mali Ong is well recognized as the best dried banana product of the country, with optimal taste compared to one made from other Kluai Namwa varieties. However, the production of Mali Ong has fluctuated substantially in recent years, leading to shortages. Consequently, farmers have turned to using other Kluai Namwa varieties including Nuanchan. This study investigated the nutraceutical contents of two popular Namwa varieties, Mali Ong and Nuanchan, at different ripening stages. Nutraceuticals in the dried banana products made from these two Kluai Namwa varieties and four commercial dried banana products were compared. Results indicated that the content of moisture, total sugar, and total soluble solids (TSS) (°Brix) increased, while total solids and texture values decreased during the ripening stage for both Kluai Namwa varieties. Rutin was the major flavonoid found in both Namwa Mali Ong and Nuanchan varieties ranging 136.00–204.89 mg/kg and 129.15–260.38 mg/kg, respectively. Rutin, naringenin, quercetin and catechin were abundant in both Namwa varieties. All flavonoids increased with ripening except for rutin, gallocatechin and gallocatechin gallate. There were no significant differences (p < 0.05) in flavonoid contents between both varieties. Tannic acid, ellagic acid, gallic acid, chlorogenic acid and ferulic acid were the main phenolic acids found in Mali Ong and Nuanchan varieties, ranging from 274.61–339.56 mg/kg and 293.13–372.66 mg/kg, respectively. Phenolic contents of both varieties decreased, increased and then decreased again during the development stage. Dopamine contents increased from 79.26 to 111.77 mg/kg and 60.38 to 125.07 mg/kg for Mali Ong and Nuanchan, respectively, but the amounts were not significantly different (p < 0.5) between the two Namwa varieties at each ripening stage. Inulin as fructooligosaccharide (FOS) increased with ripening steps. Production stages of sun-dried banana products showed no statistically significant differences (p < 0.05) between the two Namwa varieties. Therefore, when one variety is scarce, the other could be used as a replacement in terms of total flavonoids, phenolic acid, dopamine and FOS. In both Namwa varieties, sugar contents decreased after the drying process. Sugar contents of the dried products were 48.47 and 47.21 g/100 g. The drying process caused a reduction in total flavonoid contents and phenolic acid at 63–66% and 64–70%, respectively. No significant differences (p < 0.05) were found for total flavonoid and phenolic contents between the dried banana products made from the two Namwa varieties (178.21 vs. 182.53 mg/kg and 96.06 vs. 102.19 mg/kg, respectively). Products made from Nuanchan varieties (24.52 mg/kg) contained significantly higher dopamine than that from Mali Ong (38.52 mg/kg). The data also suggest that the banana maturity stage for production of the sun dried products was also optimum in terms of high nutraceutical level.

Short-chain fructooligosaccharides (sc-FOS) are prebiotics beneficial to human health, which can be synthesized from raw material containing a high sucrose content. Sugarcane syrup (SS) without molasses removal contains sucrose as a major sugar and is a rich source of several bioactive compounds. The aim of this study is to investigate factors affecting sc-FOS synthesis from SS using commercial enzyme preparations containing fructosyltransferase activity as biocatalysts. sc-FOS content increased significantly as the sucrose concentration of SS in the reaction mixture increased up to 40% (w/v). Changes in carbohydrate compositions during the transfructosylating reaction of a pure sucrose solution and SS prepared from the two sugarcane cultivars Khon Kaen 3 and Suphanburi 50, catalyzed by Pectinex Ultra SP-L and Viscozyme L, showed similar profiles. Both enzymes showed a high ability to transfer fructosyl moieties to produce sc-FOS and a plateau of the total sc-FOS concentration was observed after 4 h of reaction time. For the pure sucrose solution and SS (Suphanburi 50), Viscozyme showed a superior ability to convert sucrose to Pectinex, with a higher sc-FOS yield (g FOS/100 g of initial sucrose), GF2 or 1-kestose yield (g GF2/g of initial sucrose) and GF3 or nystose yield (g GF3/g of initial sucrose). sc-FOS syrup (FOS SS) and the foam-mat-dried syrup powder prepared from SS and FOS SS, respectively, contained a high total phenolic content and possessed higher antioxidant activities than those prepared from pure sucrose, but contained lower calories.