The aim of the current research was to evaluate the effect of pre-treatment and drying methods on the properties of dried carrots. Carrots were blanched (B) (1 or 3 min) or osmotic dehydrated (OD) (15 or 30 min) and dried by either convection (CD), microwave-convection (MW-CD), microwave-vacuum (MVD), or freeze-drying (FD). FD carrots showed the highest dry matter content (93.6–95.8%) and the lowest water activity (0.24–0.38). MVD carrots had lower dry matter content (79.5–95.8%) and two times more water activity (0.447–0.637) than FD. The highest color difference (∆E) in relation to raw material was noted in MVD samples (22–35) and the smallest in CD and FD (7–18), mainly due to the increase in brightness of the dried carrot. In general dried MCD carrot samples were characterized by the highest max force (hardness) (21.6–42.5 N; on average 34.7 N) in the breaking test and the lowest hardness was observed in the CD (10.8 N) ones. Pre-treatment and drying caused a significant decrease in the content of carotenoids (2.0–2.7 times) and chlorophyll (2.7–4.5 times) compared to the fresh carrot but a retention or increase in the total content of phenolics and antioxidant activity, especially in microwave-vacuum-dried carrots with an increase of even 2.7–2.9 times compared to raw material. High phenolic content (195.6–277.4 mg GA/100 g d.m.) was found in pre-osmotic dehydrated samples, and lower phenolic content was found in blanched samples (110.7–189.6 mg GA/100 g d.m.). Significantly, the highest average antioxidant activity was found in microwave-vacuum-dried samples (228.9 µmol Trolox/100 g d.m.). The results of this study indicate that microwave-vacuum-drying as an alternative to freeze-drying, including in combination with thermal or osmotic treatment, is very promising for the production of dried carrot snacks.

Malted gluten-free cereal grains and pseudo-cereals are interesting raw materials for producing fermented foods. The aim of the work was to assess selected technological quality characteristics and antioxidant properties of special malts in terms of use in the production of fermented foods. The research material consisted of malts made from oat, buckwheat, and brewing barley. Malting was performed on a microtechnical scale according to the standard scheme for brewing barley grain. The basic quality parameters of cereal grains obtained malts, and laboratory wort were assessed according to methods applicable in brewing. Atypical brewing malts were characterized by parameters such as malt extractability, protein solubilization, diastatic force, mash filtration time, and wort viscosity. The best results, comparable to barley malt, were obtained for naked oat malt. Malted buckwheat grains turned out to be the least biochemically modified, although their use in the production of beer and/or other fermented beverages is supported by the high content of bioactive substances and antioxidant potential. As the malting process of cereal plants improves their antioxidant properties and increases their nutritional value, oat and buckwheat malts can be successfully used to produce gluten-free fermented beverages or as an addition to fermented products, e.g., in baking and confectionery.

This study analyzed the effects of thermal pre-treatments such as convective drying (P-CD), water (BL_W), and microwave blanching (M_BL) and osmotic enrichment pre-treatments with juices from pomegranate (PG), chokeberry (CH), and sea buckthorn (SB) on microwave-vacuum-dried (MVD) carrot properties. Convective drying (CD) and freeze-drying (FD) were used as a comparative method. The dry matter content and water activity of MVD carrots were varied, but in many cases, the values were comparable to those of FD-dried carrots. Pre-enrichment in CH juice significantly reduced the values of the color parameters L*, a*, and b*, regardless of the drying method. The smallest changes were observed in microwave pre-blanching (M_BL). The lowest loss in carotenoid content was observed in CD-dried carrots (14–34 mg/100 g d.m.). Blanching and enrichment in SB juice allowed significant retention of these compounds. As a result of drying carrots, the total phenolic content (TPC) increased. Compared to the raw material, the TPC content in dried carrots increased 3–9 times. Drying using the FD and MVD methods gave a similar effect of increasing the TPC content, including a greater effect after enrichment in CH juice. The highest average antioxidant activity against the DPPH• and ABTS•+ radicals was recorded for FD-dried carrots (6.9 and 30.0 mg Trolox/g d.m.). SB juice contributed to a significant increase in the total vitamin C content, even by 89.1%, compared to raw carrots. Applying osmotic pre-enrichment in PG juice increased the sugar content in dried FD and CD samples by 37.4–49.9%, and in MVD by 21–59%.

The study investigated the effect of osmotic treatment, edible coatings, and reduced pressure on the quality of carrots dried by the microwave–vacuum method (MVD) at 3.5 or 6.5 kPa and microwave power of 250 W. Initial osmotic enrichment (OE) of carrots was carried out in chokeberry NFC juice, and osmotic dehydration (OD) in chokeberry juice concentrate. Coatings were prepared using sodium alginate or citrus pectin solutions of 1.0 or 1.5%. Osmotic treatment, and then drying pressure, had the greatest effect on increasing the dry matter (DM), total phenolic content (TPC), and color changes, but also on decreasing the water activity (AW) of dried carrot. The highest DM (average 98.7%) and the lowest AW (average 0.25) were obtained in OE carrots and dried at 3.5 kPa. Drying carrots, combined with osmotic treatment and coating, increased TPC by 13-fold, from 225 in fresh to 3229 mg GAE/100 g d.m. in dried carrots. Osmotic treatment did not affect the antioxidant activity of DPPH•, but OD significantly increased ABTS•+ compared to the raw material. Coatings had a smaller effect on color changes and antioxidant activity (DPPH• and ABTS•+) and no significant impact on DM and AW. The color changes of the control and coated samples were an increase in color lightness, redness, yellowness, and saturation (vividness), and those subjected to osmotic treatment showed a decrease in these parameters. The lower AW of dried carrots positively affected higher hardness. All samples were sensory accepted, including color, texture, and smell, especially after OD in chokeberry juice concentrate, while crunchiness was the lowest (five out of nine points).

This study evaluated the effects of selected polysaccharide edible coatings (apple pectin and sodium alginate) on the quality characteristics of fresh-cut beetroot. The changes in texture (hardness), optical parameters such as colour and Hue angle, polyphenols, flavonoids, and red and yellow colourants during 4 weeks of refrigerated storage, as well as changes in microstructure, were examined. Self-standing coatings have also been prepared and characterised by continuous structure without pores, cracks, and high lightness. The obtained results for hardness showed reduced values during storage. Colour parameters (L*, a*, and b*) and Hue angle remained mostly consistent, indicating the preservation of the desired colour, though slight changes were noted during storage. Lightness (parameter L*) increased over time, suggesting changes in the beetroot surface. However, these changes were less pronounced in samples covered with coatings. The use of polysaccharide coatings and storage time positively impacted flavonoids in fresh-cut beetroots, except after 28 days when the lowest values for both parameters were observed. It can also be noted that the polyphenol content in coated samples decreased at a slower rate. Moreover, there was a significant decrease in the content of red and yellow colourants for both control and coated samples. However, greater changes were noted for samples treated with coatings. Scanning electron microscopy used at 0 and 28 days showed lower pores in beetroot tissue as a result of applied polysaccharide coatings, and refrigerated storage negatively affected the minimally processed beetroot surface. Nevertheless, minimally processed beetroots obtained with the treatment of polysaccharide coatings as mild technology showed modifications to the quality characteristics, which can find practical use in reducing the waste of fresh-cut vegetables during storage.