Microalgae have been considered as one of the most promising biomass feedstocks for various industrial applications such as biofuels, animal/aquaculture feeds, food supplements, nutraceuticals, and pharmaceuticals. Several biotechnological challenges associated with algae cultivation, including the small size and negative surface charge of algal cells as well as the dilution of its cultures, need to be circumvented, which increases the cost and labor. Therefore, efficient biomass recovery or harvesting of diverse algal species represents a critical bottleneck for large-scale algal biorefinery process. Among different algae harvesting techniques (e.g., centrifugation, gravity sedimentation, screening, filtration, and air flotation), the flocculation-based processes have acquired much attention due to their promising efficiency and scalability. This review covers the basics and recent research trends of various flocculation techniques, such as auto-flocculation, bio-flocculation, chemical flocculation, particle-based flocculation, and electrochemical flocculation, and also discusses their advantages and disadvantages. The challenges and prospects for the development of eco-friendly and economical algae harvesting processes have also been outlined here.

Haematococcus pluvialis accumulates astaxanthin, which is a high-value antioxidant, during the red cyst stage of its lifecycle. The development of a rigid cell wall in the cysts hinders the recovery of astaxanthin. We investigated morphological changes and cell disruption of mature H. pluvialis cyst cells while using high-pressure homogenization for astaxanthin extraction. When treated with French-press-cell (pressure, 10,000–30,000 psi; passage, 1–3), the intact cyst cells were significantly broken or fully ruptured, releasing cytoplasmic components, thereby facilitating the separation of astaxanthin by ethyl acetate. Fluorescence microscopy observations using three different fluorescent dyes revealed that a greater degree of cell breakage caused greater external dispersion of astaxanthin, chlorophyll, lipids, proteins, and carbohydrates. The mechanical treatment resulted in a high cell disruption rate of up to 91% based on microscopic cell typing and Coulter methods. After the ethyl acetate extraction, the astaxanthin concentration significantly increased by 15.2 mg/L in proportion to the increase in cell disruption rate, which indicates that cell disruption is a critical factor for solvent-based astaxanthin recovery. Furthermore, this study recommends a synergistic combination of the fast instrumental particle-volume-distribution analysis and microscope-based morphologic phenotyping for the development of practical H. pluvialis biorefinery processes that co-produce various biological products, including lipids, proteins, carbohydrates, chlorophyll, and astaxanthin.

Pesticides are beneficial in protecting crops from pests and improving agricultural productivity; however, concerns on pesticide pollution in water have increased due to their indiscriminate use and lack of adequate regulations. Many studies have focused on the risks of pesticides considering the limited number and types of pesticide residues in crops and soils, and duration, and very few have focused on surface water throughout the year. Therefore, this study comprehensively identified 308 pesticides in surface water samples collected monthly over one year in the Saemangeum Basin, Korea. Both targeted and non-targeted analyses were used to identify 171 and 24 pesticides, respectively. Results highlight the extensive extent of pesticide contamination. Among the quantified pesticides, bromobutide and pretilachlor consistently exhibited high concentrations and risk levels, as indicated by their elevated risk quotient (RQ) values. Seasonal variations in pesticide concentrations revealed distinct patterns with intensified herbicide use during summer and increased insecticide concentrations during autumn. This study highlights the presence, distribution, and associated ecological risks of pesticides in surface waters, emphasizing the necessity of comprehensive monitoring and regulatory measures to protect aquatic ecosystems. The high RQ values identified for specific pesticides underscore the urgent need to implement effective strategies to mitigate these environmental risks.

Ionic liquids (ILs) are new green solvents, which are widely used in lignocellulosic and microalgal biorefineries. However, high-temperature operating conditions limit their application in the extraction of heat-labile algal products, such as bioactive astaxanthin. In this study, we report the technical feasibility of room-temperature astaxanthin extraction from Haematococcus lacustris cysts with a thick and complex cell wall structure, by combining ultrathin α-quartz nanoplates (NPLs) with ethyl-3-methylimidazolium ([Emim])-based ILs. When four different [Emim]-based ILs with thiocyanate (SCN), diethylphosphate (DEP), HSO₄, and Cl anions were applied to 90-day-old H. lacustris cysts at room temperature (~28 °C), the astaxanthin extraction efficiency was as low as 9.6–14.2%. Under sonication, α-quartz NPLs disrupted the cyst cell wall for a short duration (5 min). The astaxanthin extraction efficacies of a subsequent IL treatment improved significantly to 49.8% for [Emim] SCN, 60.0% for [Emim] DEP, 80.7% for [Emim] HSO₄, and 74.3% for [Emim] Cl ions, which were 4.4, 6.1, 8.4, and 5.2 times higher than the extraction efficacy of only ILs, respectively. This finding suggests that α-quartz NPLs can serve as powerful cell-wall-disrupting agents for the room-temperature IL-mediated extraction of astaxanthin from robust algal cyst cells.

Efficient induction of astaxanthin (AXT) biosynthesis remains a considerable challenge for the industrialization of the biorefinement of the microalga Haematococcus lacustris. In this study, we evaluated the technical feasibility of photosynthetic electrotreatment to enhance AXT accumulation in H. lacustris. The AXT content of H. lacustris electrotreated at an optimal current intensity (10 mA for 4 h) was 21.8% to 34.9% higher than that of the untreated control group, depending on the physiological state of the initial palmella cells. The contents of other carotenoids (i.e., canthaxanthin, zeaxanthin, and β-carotene) were also increased by this electrotreatment. However, when H. lacustris cells were exposed to more intense electric treatments, particularly at 20 and 30 mA, cell viability significantly decreased to 84.2% and 65.6%, respectively, with a concurrent reduction in the contents of both AXT and the three other carotenoids compared to those of the control group. The cumulative effect of electric stimulation is likely related to two opposing functions of reactive oxygen species, which facilitate AXT biosynthesis as signaling molecules while also causing cellular damage as oxidizing radicals. Collectively, our findings indicate that when adequately controlled, electric stimulation can be an effective and eco-friendly strategy for inducing targeted carotenoid pigments in photosynthetic microalgae.

The environment is a complex system composed of various creatures and pollutants caused by human activity. In this study, a mixture toxicity assessment based on the concentration-addition (CA) model was applied to 51 types of pesticides detected in the Saemangeum Watershed (the Mangyeong and Dongjin Rivers) for one year to evaluate pollution levels. A mixture toxicity assessment was conducted based on the measured environmental concentration (MEC) and the predictive values of basic ecotoxicity data (algae, daphnids, and fish). The risk and the trophic levels that showed the highest sensitivity varied depending on the sampling time and point for each mode of action (MoA) group of pesticides. In particular, the mixture risk for chloroacetamide and thiocarbamate pesticides was high (risk quotient > 1), and the potential risk was highest in autumn. In addition, the driving forces of seasonal changes were examined for samples that exhibited potential risks, and it was found that one to four substances contributed the most to the risk. The results of this study show that an initial risk assessment based on a mixture toxicity assessment can help in managing pesticide pollution in rivers.