Storage at the putative chilling threshold temperature (CTT) to avoid chilling injury still limits postharvest handling of tropical fruit like banana in that ripening may occur at the CTT. To determine whether chilling injury (CI) symptoms would develop in mature green (MG) banana fruit if the CTT exposure was extended by inhibiting ethylene action and thus ripening, 1-methylcyclopropene (1-MCP) was applied. Individual ‘fingers’ from multiple ‘clusters’ of MG bananas were either immersed in water or 50 μg L⁻¹1-MCP (a.i.) solution and each treatment was divided into three subgroups for storage at 5.0°C (severe CI), 13.0°C (mild CI), or 14.0°C (CTT) ± 0.1°C. 1-MCP delayed ripening in terms of color change for 10 days for fruit stored at the CTT. Ethylene production by fruit at 5.0°C remained around 0.04 ng kg⁻¹s⁻¹with no obvious increase during 31-day storage. Ethylene production at 14.0°C (−1-MCP/+1-MCP) increased on Day 33 while increasing on Day 38 for 13.0°C fruit without 1-MCP and on Day 39 for fruit with 1-MCP. Peak climacteric ethylene occurred on Days 44 and 39 for 13.0 and 14.0°C fruit without 1-MCP, respectively, and on Days 59 and 51 for 13.0°C and 14.0°C 1-MCP-treated fruit, respectively. As hypothesized, longer exposure of MG banana fruit to the CTT of 14.0°C without onset of ripening as was allowed by prior 1-MCP treatment allowed CI to develop at that normally non-chilling temperature. Vascular browning was the first visual and most sensitive CI symptom in the experiment and was observed on Day 4 at 5.0°C, Day 10 at 13.0°C, Day 19 at 14.0°C without 1-MCP, and on Day 28 at 14.0°C with 1-MCP. Using a 1-MCP pre-treatment to remove the influence of ethylene from bananas stored at 13°C or 14°C also resulted in slight reduction in vascular browning severity. In conclusion, a putative safe temperature may become a CI temperature if the shelf-life-limiting factor is removed, allowing longer exposure. Chilling at the CTT caused relatively mild injury on fruit, and vascular browning is a sensitive indicator of CI status, while the light-adapted quantum yield of photosystem II [Y(II)] could be a non-destructive indicator of early CI stress in MG banana. Fruit at 13.0/14.0°C developed CI symptoms slightly later with 1-MCP than without 1-MCP. This suggests that ethylene might be involved in early CI symptom development.

The involvement of stress ethylene in early chilling injury (CI) symptom development of mature-green (MG) banana fruit was examined using the ethylene action inhibitor, 1-methyclopropene (1-MCP). MG banana fruit pretreated with 0 or 50 μg L⁻¹ 1-MCP were stored at two chilling temperatures, 5 °C or 10 °C, for 0, 1, 12, or 72 h (different CI stresses), then transferred to 20 °C (rewarming) for 2 d. Irreversible CI symptoms that developed during 72 h storage at 5 or 10 °C included vascular browning and epidermal color parameters (L*, chroma, and hue angle). Some CI symptoms drastically intensified during exposure to 5 or 10 °C for 72 h, even being exacerbated after rewarming. Fruit in the other treatments suffered milder CI, and the recovery response progressed from slight and reversible to severe and irreversible with longer durations of exposure to lower temperatures. The effect of 1-MCP pretreatment was to attenuate the effect of chilling in terms of the CI symptom development (i.e., the browning of sub-epidermal tissues and the increasing of electrolyte efflux) and to promote recovery after rewarming, especially for the fruit stored at 5 °C, indicating the potential involvement of ethylene in membrane structural alterations under CI stress.