Queso Fresco has a limited shelf life and has been shown to support the rapid growth of Listeria monocytogenes during refrigerated storage. In addition to improving quality and extending shelf life, modified atmosphere packaging (MAP) has been used to control the growth of pathogenic microorganisms in foods. The objectives of this study were to determine the effects of MAP conditions on the survival and growth of spoilage microorganisms and L. monocytogenes during storage of Queso Fresco manufactured without starter cultures. For L. monocytogenes experiments, cheeses were surface inoculated at ∼4 log10 cfu/g before packaging. Inoculated and uninoculated (shelf life experiments) cheeses were placed in 75-µm high-barrier pouches, packaged under 1 of 7 conditions including air, vacuum, or combinations of N2 and CO2 [100% N2 (MAP1), 30% CO2:70% N2 (MAP2), 50% CO2:50% N2 (MAP3), or 70% CO2:30% N2 (MAP4), 100% CO2 (MAP5)], and stored at 7°C. Samples were removed weekly through 35 d of storage. Listeria monocytogenes counts were determined for inoculated samples. Uninoculated samples were assayed for mesophilic and psychrotolerant counts, lactic acid bacteria, coliforms, and yeast and mold. In general, cheeses packaged under conditions consisting of higher contents of CO2 had lower pH levels during storage compared with those stored in conditions with lower levels or no CO2 at all. Similarly, the antimicrobial efficacy of MAP in controlling spoilage microorganisms increased with increasing CO2 content, whereas conditions consisting of 100% N2, vacuum, or air were less effective. Mean L. monocytogenes counts remained near inoculation levels for all treatments at d 1 but increased ∼2 log10 cfu/g on cheeses packaged in air, vacuum, and 100% N2 (MAP1) conditions at d 7 and an additional ∼1.5 log10 cfu/g at d 14 where they remained through 35 d. In contrast, treatments consisting of 70% CO2 (MAP4) and 100% CO2 (MAP5) limited increases in mean L. monocytogenes counts to <1 log10 cfu/g through 14 d and ∼1.5 log10 cfu/g by d 21. Mean L. monocytogenes counts increased to levels significantly higher than inoculation (d 0) on cheeses stored in MAP2 and MAP3 on d 21, on d 28 for MAP4, and on d 35 for cheeses stored under MAP5 conditions. Overall, significant treatment × time interactions were observed between air, vacuum, and MAP1 when each was compared with MAP2, MAP3, MAP4, and MAP5. These data demonstrate that packaging fresh cheese under modified atmospheres containing CO2 may be a promising approach to extend shelf life while limiting L. monocytogenes growth during cold storage.

Despite efforts to control Listeria monocytogenes in dairy processing environments, contamination and subsequent outbreaks of listeriosis continue to occur. The ability of L. monocytogenes to grow during refrigerated storage necessitates strategies to prevent contamination, reduce pathogen numbers, and limit growth during storage. The objective of this study was to determine the efficacy of edible antimicrobial coatings to control L. monocytogenes on Queso Fresco (QF) when applied before [precoated (PC)] or after [preinoculated (PI)] surface contamination. Coating solutions were formulated to contain 2% chitosan and either 5% hydrogen peroxide (HP), 5% lauric arginate (LAE), 25% acidified calcium sulfate with lactic acid (ACSL), or combinations of 10% sodium caprylate (SC) with either LAE or ACSL. Fresh QF samples (25 g) were inoculated with L. monocytogenes at ~4 log CFU/g prior to, or following, antimicrobial coating application. Cheeses were then vacuum packaged and stored at 7°C for 35 days with weekly enumeration of L. monocytogenes. Aside from ACSL and LAE + SC, there was no effect of coating application timing (PC vs. PI) on the change in L. monocytogenes counts over time. Chitosan coatings without additional antimicrobials were more effective than controls but did not inhibit L. monocytogenes growth beyond 7 days. Coatings containing HP at 5% were equally effective when applied before or after L. monocytogenes inoculation, significantly reducing L. monocytogenes counts by more than 3 log CFU/g and inhibiting growth through 35 days of storage. Coatings formulated with ACSL at 25% were more effective when applied to PI cheeses but neither application produced significant reductions in L. monocytogenes counts or inhibited growth. Although LAE coatings were more effective than ACSL, neither were more effective than chitosan coatings alone. The addition of SC to ACSL and LAE coatings enhanced their antimicrobial activity as ACSL + SC and LAE + SC coatings reduced L. monocytogenes counts by >1 log CFU/g after 24 h and were listeristatic through 28 and 35 days, respectively. The identification of listericidal and listeristatic edible antimicrobial coating applications that are effective when applied before or after contamination events identifies a new approach for the control of L. monocytogenes on fresh cheese.

Dairy product recalls and dairy-related illnesses are often the result of contamination with Listeria monocytogenes, which can occur throughout the dairy production and supply chains. The use of antimicrobial compounds is one practical approach for controlling pathogen survival and growth in foods. The goal of this study was to use fluid milk as a model system to identify listeristatic or listericidal treatments that show promise for application in fluid milk and for further evaluation in other dairy products (e.g., cheese). Caprylic acid (CA), ε-polylysine (EPL), hydrogen peroxide, lauric arginate (LAE), and sodium caprylate (SC) were added individually or in combination to whole milk inoculated with L. monocytogenes at ˜4 log10 cfu/mL. Samples were stored at 7°C for 21 d, and L. monocytogenes counts were determined weekly. Inhibitory concentrations of LAE (800 mg/L) and EPL (100-400 mg/L), as well as SC and CA (3,200 mg/L each), were identified. The addition of EPL at 800 mg/L reduced L. monocytogenes counts by >3 log10 cfu/mL from initial inoculation levels after 21 d. Addition of hydrogen peroxide to milk reduced counts by >3 log10 cfu/mL from initial inoculation within 24 h (400 and 800 mg/L) or by d 7 (200 mg/L). Although the combinatory treatments of EPL + CA, EPL + LAE, and LAE + SC were characterized as indifferent, EPL + SC worked synergistically to reduce L. monocytogenes populations in milk over 21 d. Overall, these data identify potential antimicrobial treatments to control L. monocytogenes in milk and serve as a foundation for the continued development of antimicrobial controls for L. monocytogenes in dairy products.

The documented survival of pathogenic bacteria including Listeria monocytogenes (LM), shiga toxin-producing Escherichia coli (STEC), and Salmonella during the manufacture and aging of some cheeses highlights the need for additional interventions to enhance food safety. Unfortunately, few interventions are compliant with the Standards of Identity for cheese. Protective bacterial cultures (PC) represent actionable, natural interventions. However, supportive data for commercially produced PCs regarding their efficacy against pathogens and potential antagonism with each other and cheesemaking cultures are scant, thereby impeding their potential use by the cheese industry. The overall objective of this study was to identify commercially produced PCs that exert antimicrobial activity towards pathogens with minimal impact on beneficial cheese microbes. Direct antagonism and agar well diffusion assays were used to determine the impact of 10 commercially produced PCs on the growth of starter cultures and cultures of ripening bacteria and fungi. Deferred antagonism was used to evaluate the potential for antimicrobial effects against LM, STEC, and Salmonella. PCs and starter cultures were co-cultured in UHT milk to determine the effects of co-culture on starter acidification profiles when incubated according to a simulated cheese-making temperature profile (4 h at 35°C followed by 20 h at 20°C). Compatibility assays suggest that PC antagonism is microbe and strain specific. Only one PC negatively impacted the acidification of the starters tested. PC antagonism of ripening bacteria and fungi growth varied but was consistent within species. All PCs displayed deferred inhibition of LM, STEC, and Salmonella growth but to varying degrees. These data identify commercial PCs with potential for the control of pathogens and characterize their compatibility with cheesemaking cultures for future use by cheesemakers and investigations of their efficacy in the production of cheese.

The multistate Escherichia coli (E. coli) O157:H7 outbreak associated with in-shell hazelnuts highlights the pathogen’s ability to involve non-traditional vehicles in foodborne infections. Furthermore, it underscores significant gaps in our knowledge of pathogen survivability and persistence on nuts. Therefore, this study investigated the ability of E. coli O157:H7 to attach and survive on in-shell hazelnuts. In-shell hazelnuts were inoculated with a four-strain mixture of E. coli O157:H7 at 7.6 log colony forming units (CFU)/nut by wet or dry inoculation, stored at ambient conditions (24 ± 1 °C; 40% ± 3% relative humidity (RH) and sampled for twelve months. For the attachment assay, in-shell hazelnuts were inoculated and the adherent population was enumerated at 30 s⁻¹ h following inoculation. Irrespective of the inoculation method, ~5 log CFU of adherent E. coli O157:H7 was recovered from the hazelnuts as early as 30 s after inoculation. Conversely, pathogen survival was significantly reduced under dry inoculation with samples being enrichment negative after five months of storage (p < 0.05). On the other hand, wet inoculation led to a significantly longer persistence of the pathogen with ~3 log CFU being recovered from the in-shell nuts at 12 months of storage (p < 0.05). These results indicate that E. coli O157:H7 can survive in significant numbers on in-shell hazelnuts when stored under ambient conditions.