One of the major classes of mycotoxins posing serious hazards to humans and animals and potentially causing severe economic impact to the cereal industry are the trichothecenes, produced by many fungal genera. As such, indicative limits for the sum of T-2 and HT-2 were introduced in the European Union in 2013 and discussions are ongoing as to the establishment of maximum levels. This review provides a concise assessment of the existing understanding concerning the toxicological effects of T-2 and HT-2 in humans and animals, their biosynthetic pathways, occurrence, impact of climate change on their production and an evaluation of the analytical methods applied to their detection. This study highlights that the ecology of F. sporotrichioides and F. langsethiae as well as the influence of interacting environmental factors on their growth and activation of biosynthetic genes are still not fully understood. Predictive models of Fusarium growth and subsequent mycotoxin production would be beneficial in predicting the risk of contamination and thus aid early mitigation. With the likelihood of regulatory maximum limits being introduced, increased surveillance using rapid, on-site tests in addition to confirmatory methods will be required. allowing the industry to be proactive rather than reactive.

Raw feed materials are often contaminated with mycotoxins, and co-occurrence of mycotoxins occurs frequently. A total of 250 samples i.e., rice bran and maize from Cambodia, Laos, Myanmar, and Thailand were analysed using state-of-the-art liquid chromatography-mass spectrometry (LC-MS/MS) for monitoring the occurrence of regulated, emerging, and masked mycotoxins. Seven regulated mycotoxins – aflatoxins, ochratoxin A, fumonisin B₁, deoxynivalenol, zearalenone, HT-2, and T-2 toxin were detected as well as some emerging mycotoxins, such as beauvericin, enniatin type B, stachybotrylactam, sterigmatocystin, and masked mycotoxins, specifically zearalenone-14-glucoside, and zearalenone-16-glucoside. Aspergillus and Fusarium mycotoxins were the most prevalent compounds identified, especially aflatoxins and fumonisin B₁ in 100% and 95% of samples, respectively. Of the emerging toxins, beauvericin and enniatin type B showed high occurrences, with more than 90% of rice bran and maize contaminated, whereas zearalenone-14-glucoside and zearalenone-16-glucoside were found in rice bran in the range of 56–60%. Regulated mycotoxins (DON and ZEN) were the most frequent mycotoxin combination with emerging mycotoxins (BEA and ENN type B) in rice bran and maize. This study indicates that mycotoxin occurrence and co-occurrence are common in raw feed materials, and it is critical to monitor mycotoxin levels in ASEAN’s feedstuffs so that mitigation strategies can be developed and implemented.

Contamination of animal feed with multiple mycotoxins is an ongoing and growing issue, as over 60% of cereal crops worldwide have been shown to be contaminated with mycotoxins. The present study was carried out to assess the efficacy of commercial feed additives sold with multi-mycotoxin binding claims. Ten feed additives were obtained and categorised into three groups based on their main composition. Their capacity to simultaneously adsorb deoxynivalenol (DON), zearalenone (ZEN), fumonisin B1 (FB1), ochratoxin A (OTA), aflatoxin B1 (AFB1) and T-2 toxin was assessed and compared using an in vitro model designed to simulate the gastrointestinal tract of a monogastric animal. Results showed that only one product (a modified yeast cell wall) effectively adsorbed more than 50% of DON, ZEN, FB1, OTA, T-2 and AFB1, in the following order: AFB1 > ZEN > T-2 > DON > OTA > FB1. The remaining products were able to moderately bind AFB1 (44–58%) but had less, or in some cases, no effect on ZEN, FB1, OTA and T-2 binding (<35%). It is important for companies producing mycotoxin binders that their products undergo rigorous trials under the conditions which best mimic the environment that they must be active in. Claims on the binding efficiency should only be made when such data has been generated.

Several studies have reported a wide range of severe health effects as well as clinical signs, when livestock animals are exposed to high concentration of mycotoxins. However, little is known regarding health effects of mycotoxins at low levels. Thus, a long-term feeding trial (between May 2017 and December 2019) was used to evaluate the effect of low doses of mycotoxin mixtures on performance of broiler chickens fed a naturally contaminated diet. In total, 18 successive broiler performance trials were carried out during the study period, with approximately 2200 one-day-old Ross-308 chicks used for each trial. Feed samples given to birds were collected at the beginning of each trial and analysed for multi-mycotoxins using a validated LC-MS/MS method. Furthermore, parameters including feed intake, body weight and feed efficiency were recorded on a weekly basis. In total, 24 mycotoxins were detected in samples analysed with deoxynivalenol (DON), zearalenone (ZEN), fumonisins (FBs), apicidin, enniatins (ENNs), emodin and beauvericin (BEV), the most prevalent mycotoxins. Furthermore, significantly higher levels (however below EU guidance values) of DON, ZEN, FBs, BEV, ENNs and diacetoxyscirpenol (DAS) were detected in 6 of the 18 performance trials. A strong positive relationship was observed between broilers feed efficiency and DON (R² = 0.85), FBs (R² = 0.53), DAS (R² = 0.86), ZEN (R² = 0.92), ENNs (R² = 0.60) and BEV (R² = 0.73). Moreover, a three-way interaction regression model revealed that mixtures of ZEN, DON and FBs (p = 0.01, R² = 0.84) and ZEN, DON and DAS (p = 0.001, R² = 0.91) had a statistically significant interaction effect on the birds’ feed efficiency. As farm animals are often exposed to low doses of mycotoxin mixtures (especially fusarium mycotoxins), a cumulative risk assessment in terms of measuring and mitigating against the economic, welfare and health impacts is needed for this group of compounds.

The contamination of animal feed with aflatoxins is an ongoing and growing serious issue, particularly for livestock farmers in tropical and subtropical regions. Exposure of animals to an aflatoxin-contaminated diet impairs feed efficiency and increases susceptibility to diseases, resulting in mortality, feed waste, and increased production costs. They can also be excreted in milk and thus pose a significant human health risk. This systematic review and network meta-analysis aim to compare and identify the most effective intervention to alleviate the negative impact of aflatoxins on the important livestock sector, poultry production. Eligible studies on the efficacy of feed additives to mitigate the toxic effect of aflatoxins in poultry were retrieved from different databases. Additives were classified into three categories based on their mode of action and composition: organic binder, inorganic binder, and antioxidant. Moreover, alanine transaminase (ALT), a liver enzyme, was the primary indicator. Supplementing aflatoxin-contaminated feeds with different categories of additives significantly reduces serum ALT levels (p < 0.001) compared with birds fed only a contaminated diet. Inorganic binder (P-score 0.8615) was ranked to be the most efficient in terms of counteracting the toxic effect of aflatoxins, followed by antioxidant (P-score 0.6159) and organic binder (P-score 0.5018). These findings will have significant importance for farmers, veterinarians, and animal nutrition companies when deciding which type of additives to use for mitigating exposure to aflatoxins, thus improving food security and the livelihoods of smallholder farmers in developing countries.