The incidence of empyema is increasing and associated with a mortality rate of 20% in patients older than 65 years. Since 30% of patients with advanced empyema have contraindications to surgical treatment, novel, low-dose, pharmacological treatments are needed. A Streptococcus pneumoniae-induced rabbit model of chronic empyema recapitulates the progression, loculation, fibrotic repair, and pleural thickening of human disease. Treatment with single chain (sc) urokinase (scuPA) or tissue type (sctPA) plasminogen activators in doses 1.0–4.0 mg/kg were only partially effective in this model. Docking Site Peptide (DSP; 8.0 mg/kg), which decreased the dose of sctPA for successful fibrinolytic therapy in acute empyema model did not improve efficacy in combination with 2.0 mg/kg scuPA or sctPA. However, a two-fold increase in either sctPA or DSP (4.0 and 8.0 mg/kg or 2.0 and 16.0 mg/kg sctPA and DSP, respectively) resulted in 100% effective outcome. Thus, DSP-based Plasminogen Activator Inhibitor 1-Targeted Fibrinolytic Therapy (PAI-1-TFT) of chronic infectious pleural injury in rabbits increases the efficacy of alteplase rendering ineffective doses of sctPA effective. PAI-1-TFT represents a novel, well-tolerated treatment of empyema that is amenable to clinical introduction. The chronic empyema model recapitulates increased resistance of advanced human empyema to fibrinolytic therapy, thus allowing for studies of muti-injection treatments.

Bleeding within the pleural space may result in persistent clot formation called retained hemothorax (RH). RH is prone to organization, which compromises effective drainage, leading to lung restriction and dyspnea. Intrapleural fibrinolytic therapy is used to clear the persistent organizing clot in lieu of surgery, but fibrinolysin selection, delivery strategies, and dosing have yet to be identified. We used a recently established rabbit model of RH to test whether intrapleural delivery of single-chain urokinase (scuPA) can most effectively clear RH. scuPA, or single-chain tissue plasminogen activator (sctPA), was delivered via thoracostomy tube on day 7 as either one or two doses 8 h apart. Pleural clot dissolution was assessed using transthoracic ultrasonography, chest computed tomography, two-dimensional and clot displacement measurements, and gross analysis. Two doses of scuPA (1 mg/kg) were more effective than a bolus dose of 2 mg/kg in resolving RH and facilitating drainage of pleural fluids (PF). Red blood cell counts in the PF of scuPA, or sctPA-treated rabbits were comparable, and no gross intrapleural hemorrhage was observed. Both fibrinolysins were equally effective in clearing clots and promoting pleural drainage. Biomarkers of inflammation and organization were likewise comparable in PF from both groups. The findings suggest that single-agent therapy may be effective in clearing RH; however, the clinical advantage of intrapleural scuPA remains to be established by future clinical trials.

Retained hemothorax (RH) is a commonly encountered and potentially severe complication of intrapleural bleeding that can organize with lung restriction. Early surgical intervention and intrapleural fibrinolytic therapy have been advocated. However, the lack of a reliable, cost-effective model amenable to interventional testing has hampered our understanding of the role of pharmacological interventions in RH management. Here, we report the development of a new RH model in rabbits. RH was induced by sequential administration of up to three doses of recalcified citrated homologous rabbit donor blood plus thrombin via a chest tube. RH at 4, 7, and 10 days post-induction (RH4, RH7, and RH10, respectively) was characterized by clot retention, intrapleural organization, and increased pleural rind, similar to that of clinical RH. Clinical imaging techniques such as ultrasonography and computed tomography (CT) revealed the dynamic formation and resorption of intrapleural clots over time and the resulting lung restriction. RH7 and RH10 were evaluated in young (3 mo) animals of both sexes. The RH7 recapitulated the most clinically relevant RH attributes; therefore, we used this model further to evaluate the effect of age on RH development. Sanguineous pleural fluids (PFs) in the model were generally small and variably detected among different models. The rabbit model PFs exhibited a proinflammatory response reminiscent of human hemothorax PFs. Overall, RH7 results in the consistent formation of durable intrapleural clots, pleural adhesions, pleural thickening, and lung restriction. Protracted chest tube placement over 7 d was achieved, enabling direct intrapleural access for sampling and treatment. The model, particularly RH7, is amenable to testing new intrapleural pharmacologic interventions, including iterations of currently used empirically dosed agents or new candidates designed to safely and more effectively clear RH.

Background: Pharmacological treatment under conditions of slow fibrinolysis/thrombolysis requires the targeted delivery of plasminogen-activating activity. Echogenic liposomal formulations (regular TELIP) of single-chain tissue plasminogen activator (sctPA), while possessing high affinity to fibrin, contain free/loosely bound sctPA. We hypothesized that removal of free sctPA, which competes with liposomes and plasmin for fibrin, enhances unique features of the TELIP. Methods: Optimized and regular TELIP were assessed for the distribution of active sctPA (loosely bound, tightly bound, encapsulated), stability, binding to fibrin, initiating fibrinolysis in vitro and ex vivo using a battery of biochemical methods. Results: One milligram of the regular TELIP consists of 2.0–5.0 × 10⁹ echogenic liposomes (700–900 nm diameter). Non-specifically bound sctPA readily dissociates at the physiological ionic strength and pH. While up to 60% of sctPA in the regular TELIP is loosely bound with 6–15% encapsulated, and the rest is tightly bound to the liposomes; in the optimized TELIP, more than 80% of active sctPA is tightly bound with up to 40% of encapsulated. The latter is protected from high-molecular-weight ligands and could be released by an ultrasound pulse. Optimized TELIP shows low competition with plasmin for fibrin and effectively supports fibrinolysis in vitro and ex vivo. The optimized TELIP with maximal load of sctPA 3% (w/w) retains integrity at 37 °C for 5 h in vitro and up to 2 h ex vivo. Conclusions: The optimized TELIP is stable in vitro and ex vivo, does not interfere with fibrinolysis and retains a high level of encapsulated sctPA delivered precisely to the thrombus/fibrin clot.