Black soldier fly (BSF, Hermetia illucens) larvae are considered as insects with a high potential to convert organic waste into high-value products. The objective of this study was to investigate the growth performance, waste reduction efficiency, and nutritional composition of BSF reared on different ratios of coconut endosperm (C) and soybean curd residue (S), with or without supplementation, compared to standard diets (Gainesville: G and starter chicken diet: CK). Seven-day-old larvae were randomly divided into eight experimental groups (G, CK, and three different ratios of C and S with or without supplementation) with three replicates with an equal weight of larvae. The supplement contained calcium, phosphorus, amino acids, and a mineral–vitamin premix which was formulated to correlate with CK. Each replicate was terminated, measured, and evaluated when 40% of larvae had reached prepupal stage. The highest larval weight gain was presented in BSF fed CK, followed by those fed coconut endosperm and soybean curd residue at a ratio of 20:80 (C20S80), and coconut endosperm and soybean curd residue at a ratio of 50:50 (C50S50) without supplementation (numbers after C and S represent their percentage in the formulation; p < 0.001). Harvesting was delayed in the BSF fed C80S20 with and without supplementation (p < 0.001). The number of total larvae and prepupae was not significantly different between groups (p > 0.05). The greatest waste reduction efficiency was observed in the G, C50S50, and C20S80 groups without supplementation (p < 0.001). All groups with supplementation had a higher proportion of ash in both larvae and prepupae compared to non-supplemented groups (p < 0.001), but lower growth performance. The highest percentage of crude protein in larvae was presented in the Gainesville and C20S80 groups followed by the CK and C50S50 groups (p < 0.001). Equal proportions of C and S without supplementation are suggested as a rearing substrate. However, growth performance was lower than for CK; therefore, further studies could investigate cost-efficient techniques to promote this parameter.

The black soldier fly (BSF, Hermetia illucens) is considered a potential sustainable insect alternative source of protein for animal feed. The quality of a BSF meal is greatly influenced by the killing method and the purpose of this article is to compare the influences of different killing methods. BSFs at the 18-day-old prepupae stage were separated into six different killing methods with three replicates: 1. blending, 2. freezing, 3. CO₂ treatment, 4. vacuum, 5. blanching and 6. CO₂ plus blanching. After killing, BSF larvae meals were obtained by hot air oven drying and grinding. The chemical composition and in vitro digestibility calculated from sediments were not affected by the killing method, except that blending provided the worst BSF quality for all measured parameters (p < 0.05). The highest quality of BSF was obtained from the heat treatment procedures (blanching and the CO₂ plus blanching methods), as they produced lower acidity after killing, total viable counts, browning reaction (enzymatic and non-enzymatic), darkness, moisture, fat acidity, protein and lipid oxidation during storage compared with other killing procedures (p < 0.05). Interestingly, the highest free amino acids in the supernatant after in vitro digestibility of BSF samples was observed with the CO₂ plus blanching killing method (p < 0.05), whereas other parameters were similar to those obtained with blanching. The CO₂ plus blanching method did not produce clearly different outcomes to blanching; therefore, the selection of one of these techniques over the other should depend on the regulations in each country.

There has been a dramatic increase in duck meat consumption. As a result, ducks are an interesting alternative type of livestock. Animal-based proteins such as fishmeal and animal by-products are valuable nutrients with high digestibility, but they are associated with cost fluctuations, pathogen contamination, and environmental impacts. Therefore, plant-based proteins are used, but they have the disadvantages of inappropriate amino acid profiles, anti-nutritional factors, and mycotoxin contamination. Insect meal contains favorable nutrients and low production costs and is environmentally friendly; however, there is a large number of insect species. Therefore, the purpose of this investigation is to screen insects for their potential use as a protein source in the duck diet. Insect meal with a high proportion of low-digestible components was shown to have low digestibility. Yellow mealworm larvae, giant mealworm larvae, lesser wax moth larvae, house fly larvae, mulberry silkworm pupae, and American cockroach nymph have the potential to be alternative protein sources for ducks. Insect meal has been widely studied and is used in animal nutrition to replace common protein sources that have several disadvantages and to promote sustainability in animal production. Two-step in vitro digestibility using crude enzyme extracts from digestive tracts of meat-type ducks (Cherry Valley) was performed on general protein sources and insect meals to compare the in vitro digestibility of organic matter (OMd) and crude protein (CPd). Variation in chemical components between different types of insect meal was found. A positive correlation was found between OMd and the ether extract composition in insect meal, whereas a negative correlation was shown between crude fiber and acid detergent fiber. Contrasting relationships were found between CPd and crude fiber and acid detergent fiber in insect meal. In conclusion, the yellow mealworm larvae (Tenebrio molitor), giant mealworm larvae (Zophobas morio), lesser wax moth larvae (Achroia grisella), house fly larvae (Musca domestica), mulberry silkworm pupae (Bombyx mori), and American cockroach nymph (Periplaneta americana) are potential protein sources for ducks based on OMd and CPd digestibility after screening with an in vitro digestibility technique.

Silkworm (Bombyx mori L.) pupae are a by-product derived from silk production, which is often treated as waste and thus discarded: this can cause serious environmental problems and a loss of nutrients. Silkworm pupae are a rich source of protein and lipids, and the resulting protein meal can provide promising outcomes as livestock feed, notably for monogastric species. However, one possible issue that needs to be considered is the possible implication of the 1-Deoxynojirimycin (1-DNJ), a bio-compound of the silkworm that impairs glucose absorption, in poultry nutrition. Therefore, the present study evaluated the effect of the dietary inclusion of full-fat or defatted silkworm pupa meal (SWM) on the apparent digestibility of nutrients, feed choice and faecal microbiome in meat-producing quails. For the digestibility trial, a total of thirty-three 27-day-old Japanese quails (Coturnix coturnix japonica) were individually housed in digestibility cages and received three experimental diets: a control diet (control, commercial feed for fattening quails), and two other diets containing the 12.5% of either a full-fat SWM (SWM-FULL) or a defatted SWM (SWM-DEF). Subsequently, twenty-seven 33-day-old quails were simultaneously provided with Control, SWM-FULL and SWM-DEF diets for a 10-day feed choice trial. The results of the digestibility trial showed that the DM intake and excreta production were higher in both SWM groups than in the Control one (P < 0.001). The apparent digestibility of DM, organic matter, CP, ether extract, starch and energy was lower in both SWM groups than in the control group (P < 0.001), suggesting the possible implication of chitin and 1-DNJ. The feed choice test showed that quails preferred the Control diet (P < 0.001). From the microbiome analysis of the excreta, families such as Streptococcaceae (P < 0.05), Rikenellaceae and Eubacteriaceae (P < 0.01) and taxa at species level such as Lactobacillus delbrueckii (P < 0.05), Aneurinibacillus thermoaerophilus and Bacillus thermoamylovorans (P < 0.01) scored higher in SWM-FULL quails than in SWM-DEF and Control treatments. The present study demonstrated that a successful dietary inclusion of SWM for fattening quails needs to overcome the digestive criticalities caused by the of presence specific bio-compounds, namely chitin and 1-DNJ.