Increasing the milk flow rate at which milking is terminated can shorten milking time and increase milking efficiency. The effects on milk yield and composition have not been fully investigated when the take-off is set at the udder quarter level and independent of feeding during milking. The objective of this study was to investigate the effect of 3 take-off levels at the udder quarter level (0.06, 0.3, and 0.48 kg/min) applied with or without feeding during milking on milking time, milk yield, the degree of udder emptying, milk composition, and free fatty acids. In this study, 30 cows were allocated into 6 groups, balanced by lactation number, lactation stage, and milk yield, and subjected to a 3 × 2 factorial arrangement of treatments using a Latin square design. Treatments were applied for 1 wk each. This study demonstrated milking time could be reduced by applying up to a take-off level of 0.48 kg/min on udder quarter level without losing milk yield or compromising milk composition or udder health.

Artificial light can be used as a management tool to increase milk yield in dairy production. However, little is known about how cows respond to the spectral composition of light. The aim of this study was to investigate how dairy cows respond to artificial achromatic and chromatic lights. A tie-stall barn equipped with light-emitting diode (LED) light fixtures was used to create the controlled experimental light environments. Two experiments were conducted, both using dairy cows of Swedish Red and light mixtures with red, blue or white light. In experiment I, the response to light of increasing intensity on pupil size was evaluated in five pregnant non-lactating cows. In experiment II 16h of achromatic and chromatic daylight in combination with dim, achromatic night light, was tested on pregnant lactating cows during five weeks to observe long term effects on milk production, activity and circadian rhythms. Particular focus was given to possible carry over effects of blue light during the day on activity at night since this has been demonstrated in humans. Increasing intensity of white and blue light affected pupil size (P<0.001), but there was no effect on pupil size with increased intensity of red light. Milk yield was maintained throughout experiment II, and plasma melatonin was higher during dim night light than in daylight for all treatments (P<0.001). In conclusion, our results show that LED fixtures emitting red light driving the ipRGCs indirectly via ML-cones, blue light stimulating both S-cones and ipRGCs directly and a mixture of wavelengths (white light) exert similar effects on milk yield and activity in tied-up dairy cows. This suggests that the spectral composition of LED lighting in a barn is secondary to duration and intensity.

We examined the effects of substituting soybean meal with either yeast protein from Cyberlindnera jadinii or barley in concentrate feeds on feed intake, ruminal fermentation products, milk production, and milk composition in Norwegian Red (NRF) dairy cows. The concentrate feeds were prepared in pellet form as soy-based (SBM; where soybean meal is included as a protein ingredient), yeast-based (YEA; soybean meal replaced with yeast protein), or barley-based (BAR; soybean meal replaced with barley). The SBM contained 7.0% soybean meal on a dry matter (DM) basis. This was replaced with yeast protein and barley in the YEA and BAR concentrate feeds, respectively. A total of 48 early- to mid-lactation [days in milk ± standard deviation (SD): 103 ± 33.5 d] NRF cows in their first to fourth parity and with initial milk yield of 32.6 kg (SD = 7.7) were allocated into 3 groups, using a randomized block design, after feeding a common diet [SBM and good-quality grass silage: crude protein (CP) and neutral detergent fiber (NDF) content of 181 and 532 g/kg of DM, respectively] for 14 d (i.e., covariate period). The groups (n = 16) were then fed one of the dietary treatments (SBM, YEA, or BAR) for a period of 56 d (i.e., experimental period). The concentrate feeds were offered in split portions from 3 automatic feeders using electronic identification, with ad libitum access to the same grass silage. Dietary treatments had no effect on daily silage intake, total DM intake, or total NDF intake. Dietary CP intake was lower and starch intake was higher in the BAR group compared with the other groups. Ruminal fluid pH, short-chain volatile fatty acid (VFA) concentrations, acetate-to-propionate ratio, and non-glucogenic to glucogenic VFA ratio were not affected by dietary treatments. No effects of the dietary treatments were observed on body weight change, body condition score change, milk yield, energy-corrected milk yield, milk lactose and fat percentages, or their yields. In conclusion, yeast protein can substitute conventional soybean meal in dairy cow diets without adverse effect on milk production and milk composition, given free access to good-quality grass silage.

The pulsation ratio of a milking machine affects milk flow and milking time, and has also been reported to influence teat condition and milk somatic cell count (SCC). However, most studies comparing pulsation ratios have been performed on conventional cluster milking (whole-udder level), where effects such as deteriorated teat end condition and increased milk SCC are likely to be caused by over-milking on teats that are emptied faster than the other teats. When the teat cups are detached from each udder quarter separately which can be done in automatic milking systems (AMS), the risk of over-milking, especially in front teats, may be significantly reduced. This study investigated the effects of pulsation ratio on teat end condition, milk SCC, milk yield, milking time and milk flow in an automatic milking system where each udder quarter is milked separately. In total, 356 cows on five commercial farms were included in a split-udder design experiment comparing three pulsation ratios (60:40, 70:30 and 75:25) with the standard pulsation ratio (65:35) during 6 weeks. Pulsation rate was 60 cycles/min and vacuum level 46 kPa. The 70:30 and 75:25 ratios increased peak and average milk flow and the machine-on time was shorter with 75:25, while both peak and average milk flows were lower and machine-on time was longer with the 60:40 ratio. No negative effects on teat condition or milk SCC were observed with any of the pulsation ratios applied during the study. Thus it is possible that increased pulsation ratio can be used to increase milking efficiency in AMS where quarter milking is applied.

This controlled study compared the effects of 2 different gradual debonding strategies on machine milk yield, flow, and composition in a cow-driven cow-calf contact (CCC) system with automatic milking. Cows had 24 h/d access to their calves during the first weeks of lactation. In the long debonding (LDB) treatment (n = 16), a gradual reduction of cows' access to their calves was initiated 4 wk after calving over a total period of 28 d; first to 12 h/d (14 d), and then to 6 h/d (14 d). In the short debonding (SDB) treatment (n = 14), gradual reduction was initiated 6.5 wk after calving over a total period of 10 d; first to 12 h/d (5 d), and then to 6 h/d (5 d). From 6 h/d, access was finally reduced to 0 h/d for 7 d for both treatments. Machine milk yield, somatic cell count, and peak and average milk flow were automatically registered at milking. During the 9-wk study period, composite samples were analyzed for milk composition. Data were analyzed with linear mixed effect models. Results showed that machine milk yield during 24 h/d access varied between cows (range 1.2-49.9 kg/d, average ± standard deviation 13.2 ± 7.82 kg/d). The LDB cows had a higher daily machine milk yield than SDB cows at the end of and after access reduction was completed (+5.0 ± 1.63 and +5.1 ± 1.55 kg during the last 5 d of 6 h/d access, and 0 h/d access, respectively). Somatic cell count was on a healthy level, with no difference between treatments. Milk fat content increased with reduction in access, regardless of treatment. Short debonding cows tended to show higher milk protein content and lower milk lactose content than cows with a longer debonding. This study has shown that a longer debonding initiated earlier may give a higher milk yield in the short term. The variation in machine milk yield may indicate differences in milk ejection, suckling, and visiting patterns and preferences among cows.

Prolonged cow-calf contact (CCC) is of growing importance to the dairy sector due to increasing societal interest, implementation of CCC on farms, and research efforts. Incorporating CCC into dairy systems may be a polarizing change for academics and farmers. However, by considering the challenges with curiosity, including those mutual to CCC and non-CCC systems, there may be an opportunity to collectively improve the management of dairy animals. The aim of this review was to describe current issues and constraints in CCC, propose opportunities to advance knowledge of CCC, and inspire forward-thinking questions for dairy systems. There are known challenges for CCC implementation, such as research reproducibility (e.g., suitable controls, validity types) and on-farm application (e.g., farmer perspectives, policies, and corporate standards). To facilitate practical solutions for farmers wanting to adopt CCC we need research describing the effects of CCC systems on animal health and behavior. Already researchers have begun to explore cow and calf performance and health, methods for decreasing stress at weaning and separation (e.g., duration of contact, gradual weaning), foster cows, and opportunities for positive animal welfare in CCC systems (e.g., affiliative and play behavior). However, because dairying takes place in a complex system, changes may affect different facets of the system's sustainability. We suggest that the development of CCC systems should happen in dialog with stakeholders. Cow-calf contact is an uncommon practice in dairy systems and exists in different contexts; thus, there are many questions to address before advice can be given to interested dairy stakeholders. Perhaps, these CCC-related questions are an invitation to contemplate how we want dairy systems to look like in 30 years.