Biosynthetic nerve grafts are developed in order to complement or replace autologous nerve grafts for peripheral nerve reconstruction. Artificial nerve guides currently approved for clinical use are not widely applied in reconstructive surgery as they still have limitations especially when it comes to critical distance repair. Here we report a comprehensive analysis of fine-tuned chitosan nerve guides (CNGs) enhanced by introduction of a longitudinal chitosan film to reconstruct critical length 15 mm sciatic nerve defects in adult healthy Wistar or diabetic Goto-Kakizaki rats. Short and long term investigations demonstrated that the CNGs enhanced by the guiding structure of the introduced chitosan film significantly improved functional and morphological results of nerve regeneration in comparison to simple hollow CNGs. Importantly, this was detectable both in healthy and in diabetic rats (short term) and the regeneration outcome almost reached the outcome after autologous nerve grafting (long term). Hollow CNGs provide properties likely leading to a wider clinical acceptance than other artificial nerve guides and their performance can be increased by simple introduction of a chitosan film with the same advantageous properties. Therefore, the chitosan film enhanced CNGs represent a new generation medical device for peripheral nerve reconstruction.

Nerve injuries extend from simple nerve compression lesions to complete nerve injuries and severe lacerations of the nerve trunks. A specific problem is brachial plexus injuries where nerve roots can be ruptured, or even avulsed from the spinal cord, by traction. An early and correct diagnosis of a nerve injury is important. A thorough knowledge of the anatomy of the peripheral nerve trunk as well as of basic neurobiological alterations in neurons and Schwann cells induced by the injury are crucial for the surgeon in making adequate decisions on how to repair and reconstruct nerves. The technique of peripheral nerve repair includes four important steps (preparation of nerve end, approximation, coaptation and maintenance). Nerves are usually repaired primarily with sutures applied in the different tissue components, but various tubes are available. Nerve grafts and nerve transfers are alternatives when the injury induces a nerve defect. Timing of nerve repair is essential. An early repair is preferable since it is advantageous for neurobiological reasons. Postoperative rehabilitation, utilising the patients' own coping strategies, with evaluation of outcome are additional important steps in treatment of peripheral nerve injuries. In the rehabilitation phase adequate handling of pain, allodynia and cold intolerance are emphasised.

In this review we summarize the events known to occur after an injury in the peripheral nervous system. We have focused on the Schwann cells, as they are the most important cells for the repair process and facilitate axonal outgrowth. The environment created by this cell type is essential for the outcome of the repair process. The review starts with a description of the current state of knowledge about the initial events after injury, followed by Wallerian degeneration, and subsequent regeneration. The importance of surgical repair, carried out as soon as possible to increase the chances of a good outcome, is emphasized throughout the review. The review concludes by describing the target re-innervation, which today is one of the most serious problems for nerve regeneration. It is clear, compiling this data, that even though regeneration of the peripheral nervous system is possible, more research in this area is needed in order to perfect the outcome.

A nerve injury has a profound impact on the patient’s daily life due to the impaired sensory and motor function, impaired dexterity, sensitivity to cold as well as eventual pain problems. To perform an appropriate treatment of nerve injuries, a correct diagnosis must be made, where the injury is properly classified, leading to an optimal surgical approach and technique, where timing of surgery is also important for the outcome. Knowledge about the nerve regeneration process, where delicate processes occur in neurons, non-neuronal cells (i.e. Schwann cells) and other cells in the peripheral as well as the central nervous systems, is crucial for the treating surgeon. The surgical decision to perform nerve repair and/or reconstruction depends on the type of injury, the condition of the wound as well as the vascularity of the wound. To reconnect injured nerve ends, various techniques can be used, which include both epineurial and fascicular nerve repair, and if a nerve defect is caused by the injury, a nerve reconstruction procedure has to be performed, including bridging the defect using nerve-grafts or nerve transfer techniques. The patients must be evaluated properly and regularly after the surgical procedure and appropriate rehabilitation programmes are useful to improve the final outcome. Cite this article: EFORT Open Rev 2017;2. DOI: 10.1302/2058-5241.2.160071. Originally published online at www.efortopenreviews.org

Background: To study costs and outcome for serious hand and arm injuries during the first year after the trauma. Methods: In patients with a Hand Injury Severity Score (HISS) > 50, DASH and EQ-5D scores as well as factors related to costs within the health care sector, costs due to lost production and total costs were evaluated. Cox-regression analysis stratifying for mechanism of injury was used to analyse return to work. Results: The majority of the 45 included patients (median 42 years 16–64) were men with severe (n = 9) or major (n = 36) injuries with different type of injuries (amputations n = 13; complex injuries n = 18; major nerve injuries/full house n = 13; burn injury n = 1). DASH and EQ-5D decreased and increased, respectively, significantly over time during one year. Total costs (+34%) and costs of lost production were highest for persons injured at work. Factors associated with higher health care costs were age >50 years (+52%), injury at work (+40%) and partial labour market activity (+66%). Costs of lost production had a significant role in total costs of injury. Patients with major injuries had longer duration of sick leave. Patients with severe injuries were more likely to return to work [(RR 3.76 (95% CI 1.38-10.22) from Cox regression, controlling for age, gender and presence of nerve injury]. Conclusions: Despite the fact that work environments have constantly improved over the last decades, we found that hand injuries at work were most costly both in terms of health care and costs of lost production, although the severity, i.e. HISS, did not differ from injuries occurring at home or during leisure.

A delay in surgical nerve repair results in impaired nerve function in humans, but mechanisms behind the weakened nerve regeneration are not known. Activating transcription factor 3 (ATF3) increases the intrinsic growth state of injured neurons early after injury, but the role of long-term changes and their relation to axonal outgrowth after a delayed nerve repair are not well understood. ATF3 expression was examined by immunohistochemistry in motor and sensory neurons and in Schwann cells in rat sciatic nerve and related to axonal outgrowth after transection and delayed nerve repair (repair 0, 30, 90 or 180 days post-injury). Expression of the neuronal cell adhesion molecule (NCAM), which is expressed in non-myelinating Schwann cells, was also examined.