Nowadays, the consumer seeks to replace synthetic preservatives with biopreservation methods, such as sourdough in bread. Lactic acid bacteria (LAB) are used as starter cultures in many food products. In this work, commercial yeast bread and sourdough breads were prepared as controls, as well as sourdough breads with L. plantarum 5L1 lyophilized. The impact of L. plantarum 5L1 on the properties of bread was studied. Antifungal compounds and the impact on the protein fraction by the different treatments in doughs and breads were also analyzed. In addition, the biopreservation capacity of the treatments in breads contaminated with fungi was studied and the mycotoxin content was analyzed. The results showed significant differences with respect to the controls in the properties of the bread and a higher total phenolic and lactic acid content in breads with higher amounts of L. plantarum 5L1. In addition, there was a higher content of alcohol and esters. Furthermore, adding this starter culture produced hydrolysis of the 50 kDa band proteins. Finally, the higher concentration of L. plantarum 5L1 delayed fungal growth and reduced the content of AFB1 and AFB2 compared to the control.

Fungal spoilage is one of the main reasons of economic losses in the food industry, especially in the wine sector. Consequently, the search for safer and new preservation techniques has gained importance in recent years. The objective of this study was to investigate the antifungal and anti-mycotoxigenic activity from 28 microorganisms (MO) isolated from red grape. The antifungal activity of a cell free supernatant of fermented medium by the isolated MO (CFS) was tested with the agar diffusion method and the minimum inhibitory concentration (MIC) and minimum fungicidal concentration (MFC) assay. Additionally, different antifungal compounds from the CFS were identified and quantified (organic acids, phenolic compounds, and volatile organic compounds). Finally, the most active CFS were tested as red grape bio-preservative agents. Results evidenced that CFS fermented by the strain UTA 6 had the highest antifungal activity, above all isolates, and produced a wide pool of antifungal compounds. The use of UTA 6 CFS as bio-preservative agent showed a reduction of 0.4 and 0.6 log₁₀ spores per gram of fruit in grapes contaminated by A. flavus and B. cinerea, respectively. Moreover, UTA 6 CFS treatment reduced the occurrence of aflatoxin B₁ and fumonisin (B₂, B₃, and B₄) production in grapes contaminated by 28–100%.

Food bio-preservatives are requested as substituents of chemical pesticides in food. The aim of this study was to carry out a screening of twenty biocontrol agents (BCAs) for their potential fungicidal activity in vitro. Twenty BCAs were tested against ten pathogenic fungi. Some of the cell-free supernatants (CFS) tested showed in vitro antifungal activity versus pathogenic fungi. The highest fungicidal activity was observed in the fermented CFS of Paenibacillus chibensis CECT 375, Bacillus amyloliquefaciens CECT 493, and Pantoea agglomerans CECT 850, which showed a minimum inhibitory concentration (MIC) and minimum fungicidal concentration (MFC) values of 125 and 250 g/L, respectively. The compounds responsible for the antifungal activity, such as organic and phenolic acids, were determined. Lactic acid, acetic acid, benzoic acid, and phenyllactic acid among others can be related to antifungal activity. HPLC-MS/MS analysis showed a reduction of ochratoxin A (OTA) and aflatoxin B₁ (AFB₁) up to 26% (Paenibacillus alvei CECT 2) and 55% (Paenibacillus polymyxa CECT 155), respectively. The present study prompts that metabolism products of BCAs are propitious for the bioconservation of food, due to their ability to reduce the proliferation of mycotoxigenic fungi and mycotoxins production.

Traditional sourdough is obtained using a mixture of flour and water stored at room temperature until acidification. Therefore, adding lactic acid bacteria (LAB) can improve the quality and safety of sourdough bread. Faced with this problem, four drying techniques—freeze-drying, spray-drying, low-temperature drying, and drying at low humidity—have been applied. Our goals were to isolate LAB strains with antifungal potential against Aspergillus and Penicillium fungi. The antifungal capacity was evaluated with agar diffusion, co-culture in overlay agar, and a microdilution susceptibility assay. In addition, the antifungal compounds generated in sourdough were analyzed. As a result, dried sourdoughs were prepared with Lactiplantibacillus plantarum TN10, Lactiplantibacillus plantarum TF2, Pediococcus pentosaceus TF8, Pediococcus acidilactici TE4, and Pediococcus pentosaceus TI6. The minimum fungicidal concentrations ranged from 25 g/L versus P. verrucosum and 100 g/L against A. flavus. A total of 27 volatile organic compounds were produced. Moreover, the lactic acid content reached 26 g/kg of dry product, and the phenyllactic concentration was significantly higher than the control. The P. pentosaceus TI6 exhibited a higher antifungal capacity in vitro and demonstrated a higher production of antifungal compounds compared to the other strains; therefore, further studies will evaluate the impact of this sourdough in bread manufacture.