The bovine endopeptidase cathepsin D was investigated regarding its temperature-dependent inactivation and ability to form bitter peptides within a spiked model fresh cheese. Cathepsin D was found to be more susceptible than other milk endogenous peptidases to temperature treatments in skim milk. Inactivation kinetics revealed decimal reduction times of 5.6 min to 10 s in a temperature range from 60 to 80°C. High temperature and ultra-high temperature (UHT) treatments from 90 to 140°C completely inactivated cathepsin D within 5 s. A residual cathepsin D activity of around 20% was detected under pasteurization conditions (72°C for 20 s). Therefore, investigations were done to estimate the effect of residual cathepsin D activity on taste in a model fresh cheese. The UHT-treated skim milk was spiked with cathepsin D and acidified with glucono-δ-lactone to produce a model fresh cheese. A trained bitter-sensitive panel was not able to distinguish cathepsin D-spiked model fresh cheeses from the control model fresh cheeses in a triangle test. Model fresh cheese samples were also analyzed for known bitter peptides derived from casein fractions using a HPLC-tandem mass spectrometry (MS) approach. In accordance with the sensory evaluation, the MS analyses revealed that the bitter peptides investigated within the cathepsin D-spiked model fresh cheese were not found or were below the limit of detection. Even though cathepsin D may be present during the fermentation of pasteurized milk, it does not seem to be responsible for bitter peptide formation from milk proteins on its own.

Calcium- and protein-rich fermented milk products, such as concentrated yoghurts and fresh cheeses, may contain undesired bitter peptides, which are generated by the proteolytic cleavage of casein. Up to now, it is not clear whether this process is caused by endogenous milk enzymes, such as plasmin and cathepsin D, or whether proteolytic enzymes from applied starter cultures, such as the lactococcal cell-envelope peptidase PrtP, are involved. A sensory analysis of fresh cheese products made from milk concentrates fermented with prtP-negative and -positive Lactococcus lactis strains revealed bitterness in the products fermented with prtP-positive L. lactis strains. Two prtP-positive strains, LTH 7122 and LTH 7123, were selected to investigate the effect of increased calcium concentrations (additional 5 mM and 50 mM CaCl₂) at neutral (pH 6.6) and acidic (pH 5.5) pH-values on the transcription of the prtP gene and its corresponding PrtP peptidase activity in milk citrate broth (MCB). For both strains, it was shown that prtP transcription was upregulated only under slightly elevated calcium conditions (5 mM CaCl₂) after 5 h of growth. In concordance with these findings, PrtP peptidase activity also increased. When higher concentrations of calcium were used (50 mM), prtP expression of both strains decreased strongly by more than 50%. Moreover, PrtP peptidase activity of strain LTH 7123 decreased by 15%, but enzymatic activity of strain LTH 7122 increased slightly during growth under elevated calcium concentrations (50 mM CaCl₂). Fermentations of reconstituted casein medium with 3.4% (w/v) and 8.5% (w/v) protein and different calcium concentrations using strain LTH 7122 revealed no clear relationship between prtP transcription and calcium or protein concentration. However, an increase in PrtP peptidase activity under elevated protein and calcium conditions was observed. The activity increase was accompanied by increased levels of bitter peptides derived from different casein fractions. These findings could be a possible explanation for the bitterness in fermented milk concentrates that was detected by a trained bitter panel.

Enzymatic deamidation using protein-glutamine glutaminases (PGs) is a promising method for improving the solubility, foaming properties, and emulsifying properties of plant proteins. This study compared the deamidation of various plant proteins using PGs from Chryseobacterium proteolyticum (PGC), Bacteroides helcogenes (PGB), and Flavobacterium sp. (PGF) and examined the effects on the foaming and emulsifying properties of sunflower and oat proteins. PGB produced the largest increases in protein solubility, though PGF usually gave the highest maximal degree of deamidation (DD(max)). For oat protein, all PGs reduced maximum foam volume (V_F(max)), but PGC and PGB doubled foam half-time (t_{1/2 foam}). For sunflower protein, PGB reduced V_F(max), while PGC increased t_{1/2 foam} by up to 17.5-fold. Thus, different PGs affect techno-functional properties distinctly, reflecting different substrate specificities. Improvements in solubility, foaming, and emulsifying properties are not dependent on achieving the highest DD(max). Expanding the range of available PGs would allow for better matching to plant substrates and enhance industrial applicability.