Throughout the last decades the developments on desalination field have been focused on energy consumption and costs reduction. However, water recovery and brine disposal are becoming a matter of concern to desalination industry. In this work, a Zero Liquid Discharge (ZLD) unit coupled with a Solar Micro Gas Turbine (SMGT) system is presented to address, among others, the challenges of mining industry in remote areas, in particular, fossil fuel dependence, water availability and pollution derived from effluents disposal. As a way to assess the feasibility of the proposal, a techno-economic analysis of the application in two Southern American regions (Chile and Ecuador) of photovoltaic modules, wind turbines and Solar Micro Gas Turbines is performed. Afterwards, the main novel feature of the new system—i.e., the ZLD unit—is described and a sensitivity analysis on its functioning whilst coupled with the SMGT is carried out. The aim is to propose a preliminary design of the ZLD process. The selection of the optimal ratio between exhaust gases and brine mass flow rates is analyzed, as well as variation in inlet salinity and temperatures. Furthermore, the water which could be recovered from effluents, at the same time that the heat of exhaust gases from SMGT is harvested, is quantified. Lastly, according to the results obtained, a preliminary design of a 10 kWe rated power SMGT system, coupled to Reverse Osmosis (RO) and ZLD units, is proposed.

This manuscript investigates the supercritical carbon dioxide (sCO${}_2$) power cycle employed in the power block of concentrated solar power (CSP) plants—solar tower—as an alternative for solar desalination, developed with either distillation or reverse osmosis. This concept is investigated as a possible up-scaling of the SOLMIDEFF project, originally based on a hot-air micro gas turbine combined with a solar dish collector. For the upscaled concept, five different sCO${}_2$ cycles are considered, chosen amongst the best-performing configurations proposed in the literature for CSP applications, and modelled with Thermoflex software. The influence of ambient conditions is studied, considering two minimum cycle temperatures (35 °C and 50 °C), corresponding to Santa Cruz de Tenerife and Abu Dhabi, respectively. The results show that the low temperatures at the inlet of the heat rejection unit compromise the viability of distillation technologies. On the other hand, the high thermal efficiency achieved by these cycles, especially with the recompression and partial cooling layouts, reduces the specific energy consumption when combined with reverse osmosis (RO), below that of photovoltaic (PV)+RO. Feed-water preheating is explored as a solution to further reduce energy consumption, concluding that its actual interest is not clear and strongly depends on the location considered and the corresponding water quality standards.