The fate of five Fusarium toxins — deoxynivalenol (DON), sum of 15- and 3-acetyl-deoxynivalenol (ADONs), HT-2 toxin (HT-2) representing the main trichothecenes and zearalenone (ZON) during the malting and brewing processes — was investigated. In addition to these ‘free’ mycotoxins, the occurrence of deoxynivalenol-3-glucoside (DON-3-Glc) was monitored for the first time in a beer production chain (currently, only DON and ZON are regulated). Two batches of barley, naturally infected and artificially inoculated with Fusarium spp. during the time of flowering, were used as a raw material for processing experiments. A highly sensitive procedure employing high-performance liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) was validated for the analysis of ‘free’ Fusarium mycotoxins and DON-conjugate in all types of matrices. The method was also able to detect nivalenol (NIV), fusarenon-X (FUS-X) and T-2 toxin (T-2); nevertheless, none of these toxins was found in any of the samples. While steeping of barley grains (the first step in the malting process) apparently reduced Fusarium mycotoxin levels to below their quantification limits (5–10 µg kg⁻¹), their successive accumulation occurred during germination. In malt, the content of monitored mycotoxins was higher compared with the original barley. The most significant increase was found for DON-3-Glc. During the brewing process, significant further increases in levels occurred. Concentrations of this ‘masked’ DON in final beers exceeded ‘free’ DON, while in malt grists this trichothecene was the most abundant, with the DON/DON-3-Glc ratio being approximately 5:1 in both sample series. When calculating mass balance, no significant changes were observed during brewing for ADONs. The content of DON and ZON slightly decreased by a maximum of 30%. Only traces of HT-2 were detected in some processing intermediates (wort after trub removal and green beer).

Ten different barley cultivars and their corresponding malts were used to obtain different fractions. Phenolics extracted belonged to free, soluble esters and insoluble-bound fractions. Total phenolic content (TPC) of the free fraction, as measured according to the Folin-Ciocalteu method, ranged from 37.7 to 167.2 mg gallic acid equiv/kg of dried material (GAE/kg_dw) for barley and between 34.1 and 72.3 mg GAE/kg_dw for malt. The bound phenolic content ranged from 210.3 to 320.5 and between 81.1 and 234.9 mg GAE/kg_dw for barley and malt, respectively. The contribution of bound phenolics to the TPC was significantly higher than that of free and esterified fractions. Catechin and ferulic acid, quantified by high performance liquid chromatography with diode array detector (HPLC-DAD), were the most abundant phenolics in the free and bound fractions, respectively. The p-coumaric acid content was lower in hulless genotypes, as compared to hulled genotypes, showing that it is mainly concentrated in the hull. The antioxidant activities of the phenolic fractions were investigated using the radical scavenging assay (DPPH) and ferricyanide reducing power. The bound phenolics demonstrated a significantly higher antioxidant capacity compared to the free and esterified phenolics. During the malting process, a significant decrease of the bound phenolics was observed with a corresponding increase of the esterified fraction.

The attractive prospect of a continuous beer fermentation system consists mostly of the accelerated transformation of wort into beer. Although continuous beer fermentation has been studied as a promising technology for several decades, the number of industrial applications is still limited. The major obstacle hindering the extensive industrial exploitation of this technology is the difficulty in achieving the correct balance of sensory compounds in the short time typical for continuous systems. This paper offers an integral view on the particularities of continuous systems, which may impart beer a sensorial character distinct from conventionally fermented counterparts. The main groups of flavour active compounds are discussed from the perspective of possible control strategies by means of process parameters and strain selection.

Hop (Humulus lupulus L.), as a key ingredient for beer brewing, is also a source of many biologically active molecules. A notable compound, 8-prenylnaringenin (8-PN), structurally belonging to the group of prenylated flavonoids, was shown to be a potent phytoestrogen, and thus, became the topic of active research. Here, we overview the pharmacological properties of 8-PN and its therapeutic opportunities. Due to its estrogenic effects, administration of 8-PN represents a novel therapeutic approach to the treatment of menopausal and post-menopausal symptoms that occur as a consequence of a progressive decline in hormone levels in women. Application of 8-PN in the treatment of menopause has been clinically examined with promising results. Other activities that have already been assessed include the potential to prevent bone-resorption or inhibition of tumor growth. On the other hand, the use of phytoestrogens is frequently questioned regarding possible adverse effects associated with long-term consumption. In conclusion, we emphasize the implications of using 8-PN in future treatments of menopausal and post-menopausal symptoms, including the need for precise evidence and further investigations to define the safety risks related to its therapeutic use.