The objective of the present study was to investigate the effect of ripening and preservation containers on the physico-chemical, microbiological, and textural characteristics, and volatile profile of white cheese. White cheeses were manufactured on an industrial scale using large-capacity stainless steel tanks (SST) of 500 kg, and the respective control samples in tin containers (TC) of 17 kg. No significant differences (p > 0.05) in fat in dry matter and total protein content were observed at 60 days of ripening between the TC and SST cheeses. After 60 days, of ripening, the moisture of the cheeses in SST and TC did not show significant statistical differences (p > 0.05). No significant differences (p > 0.05) were observed between the TC and SST cheeses in the mineral concentration (Ca, Mg, K, and Na) and textural characteristics. Similar results of pH and bacterial counts, as well as absence of yeasts and molds, were observed during ripening and preservation time in both groups of cheeses. Furthermore, proteolysis was not affected statistically significantly (p > 0.05). A moderately increased rate of ripening for the cheeses in TC was observed up to 90 days but, at 180 days, proteolysis was similar in both groups of cheeses. Regarding the SFA, MUFA, and PUFA content, no significant differences (p > 0.05) were observed between the TC and SST cheeses. A total of 94 volatile compounds were identified in the volatile fraction of both the SST and TC cheeses. Organic acids and alcohols were the most abundant classes of volatile compounds that were identified. The flavor and texture scores in the TC and SST cheeses were similar (p > 0.05). Overall, the TC and SST cheeses did not show any significant statistical difference in any of the analyzed parameters.

Yogurt acid whey (YAW), a by-product of strained yogurt production, is a strong environmental pollutant because of its high organic load. Hence, efforts are made for its utilization to minimize its disposal in the environment. This study deals with the incorporation of YAW in yogurt ice cream (YIC) by partial replacement of yogurt with simultaneous lactose hydrolysis (LH) of the formulated YIC mix. Six YIC mix formulations were made, two without YAW (non-LH- and LH-control samples, A and AH), two with 12.5% YAW (samples B and BH), and two with 18.75% YAW (samples C and CH). The results showed that the partial replacement of yogurt with YAW decreased significantly (p < 0.05) the total solids of B, BH, C, and CH products (31.72 ± 0.14%, 31.92 ± 0.21%, 30.94 ± 0.14%, and 31.27 ± 0.10%, respectively) compared to the total solids of control products A and AH (33.30 ± 0.36% and 33.74 ± 0.06%, respectively). In contrast, the overruns increased (51.50 ± 2.36%, 58.26 ± 0.09%, 56.86 ± 1.92%, and 65.52 ± 1.30% for the B, BH, C, and CH products, respectively) compared to control samples (42.02 ± 2.62% and 49.53 ± 2.12% for A and AH, respectively). LH significantly decreased the freezing point and the viscosity of the YIC mixes but increased the overruns of the products as shown previously. YAW significantly decreased the hardness of the B and C products (56.30 ± 2.11 N and 43.43 ± 3.91 N, respectively) compared to control A (81.14 ± 9.34 N), and LH decreased it even more, leading to a rather soft scoop YIC. AH, BH, and CH YICs exhibited better melting properties despite the lack of fat destabilization in all samples. After 60 days of storage, counts of yogurt starter microorganisms were still >10⁷ cfu/g and DPPH radical scavenging activity had increased in all products. In the sensory evaluation test, lactose-hydrolyzed samples AH, BH, and CH had less intense sandiness and, as expected, more intense sweetness. In conclusion, in the framework of the circular economy, it is possible for the YAW to be used as a resource material at a ratio of 12.5% to produce a YIC product without leaving behind any new waste.

The acid whey derived during the production of Greek yoghurt, i.e., yoghurt acid whey (YAW), is considered as environmental pollutant due to its low pH and high lactose content. YAW may be obtained by centrifugation or ultrafiltration or filtration through cloth bags (traditional method) of the initial yoghurt, methods that could affect its composition. In the last years, efforts have been made to improve its composition using membrane technology. In the present work, the composition of 35 different YAW samples from Greek Yoghurt dairies was studied. The YAW samples were grouped according to the way of production and the kind of milk in the case of the traditional method. The results showed that both the kind of milk and the way of yoghurt staining affected its composition. Ovine YAW derived from traditional straining was richer in lactic acid and calcium than bovine YAW. Moreover, the composition of bovine YAW varied among the different ways of straining, and this affected its behaviour during membrane processing. Nanofiltration of three representative bovine YAW samples and one ovine YAW sample at their natural pH, i.e., pH 4.5, and at 25 °C removed the lactic acid at a range from 40 to 55%, and the monovalent cations > 60% and retained lactose and galactose at percentages > 95% and 80% respectively.