The objective of this study was to determine the grinding characteristics of wheat with a low moisture content. Two kinds of wheat—soft spelt wheat and hard Khorasan wheat—were dried at 45 °C to reduce the moisture content from 12% to 5% (wet basis). Air drying at 45 °C and storage in a climatic chamber (45 °C, 10% relative humidity) were the methods used for grain dehydration. The grinding process was carried out using a knife mill. After grinding, the particle size distribution, average particle size and grinding energy indices were determined. In addition, the dough mixing properties of wholemeal flour dough were studied using a farinograph. It was observed that decreasing the moisture content in wheat grains from 12% to 5% made the grinding process more effective. As a result, the average particle size of the ground material was decreased. This effect was found in both soft and hard wheat. Importantly, lowering the grain moisture led to about a twofold decrease in the required grinding energy. Moreover, the flour obtained from the dried grains showed higher water absorption and higher dough stability during mixing. However, the method of grain dehydration had little or no effect on the results of the grinding process or dough properties.

Parsley leaves (PL) are a rich source of many bioactive compounds and show many health-promoting properties. The aim of this study is to analyze the effect of the addition of PL to wheat flour on the physical, antioxidant, and sensory properties of wheat bread. Wheat flour was partially substituted with 0, 1, 2, 3, 4, and 5% PL. Bread dough was prepared using the direct method. Bread loaves were cooled, and then their volume, texture, color, total phenolic content, and antioxidant activity were evaluated. In addition, a sensory evaluation of bread was performed. Incorporation of PL into wheat decreased the bread volume and increased the crumb moisture but had little influence on the crumb texture. The crumb of the enriched bread was darker and greener compared with the control sample. PL addition increased the redness of the crumb as well. The total color difference for the enriched bread ranged from 9.3 to 21.4. According to the sensory evaluation, the amount of wheat flour added to PL should not exceed 3%. Such a kind of bread showed about a twofold higher level of phenolic compounds and enhanced antioxidant activity compared with the control bread. This study showed that powdered PL can be a valuable nutritional supplement to wheat bread. Future research should focus on the possibilities of fortifying various types of food with this additive.

The aim of this study was to evaluate the baking value of rye flours from industrial mills and to indicate which rye flour quality parameters are the most important predictors of wholemeal rye bread quality for commercially milled rye grains. Ten wholemeal rye flours, which were characterized by ash content ranging from 1.43% to 2.42% d.m. (dry mass), were used for the study. The parameters that characterize the flour properties and the baking test were assessed. The study revealed that for the analyzed commercial rye flours, the falling number test and the amylograph properties are insufficient parameters for predicting the quality of wholemeal rye bread. The manufacture of good quality wholemeal bread requires the use of rye flour with superior quality, such as fine granulation, low protein content, low total and insoluble pentosans content, and, in particular, a high percentage of water-soluble pentosans content. Breads with a higher volume were obtained from rye flours that were generally characterized by lower protein content, lower total and insoluble pentosans content, and higher water-soluble pentosans content. Flour granulation and the percentage of water-soluble pentosans content especially, had a significant impact on bread’s hardness of crumb and the hardness of crumb’s increase during bread storage.

Triticale (× Triticosecale Wittmack), developed by crossing rye and wheat, is increasingly applied in food production. The aim of this paper was to study the grinding process of eight new triticale grain (TG) varieties harvested in 2020 and 2021. TG was tempered to 12% of moisture and a knife mill was used for the size reduction. The following parameters characterizing the grinding process of TG were determined: specific grinding energy, Sokołowski grinding index, particle size distribution and average particle size. Additionally, the basic chemical composition, total phenolic content and antiradical activity of TG were determined. The protein content of TG was strongly influenced both by the variety and harvesting year, while other components were mostly affected by the genetic factor. The strongest influence on the grinding indices has a variety of TG. Specific grinding energy varied in the range of 14.0 kJ kg⁻¹–17.8 kJ kg⁻¹ and was positively correlated with the size of ground particles. Especially, the grain of Belcanto required lower grinding energy requirements and showed the strongest antioxidant capacity compared with other varieties of TG.

In this study, we studied the drying process, grinding characteristics and physicochemical characteristics of broccoli sprouts (BS). The seeds of broccoli were germinated at 20 °C for 3 and 6 days. Then, the seeds were air- and freeze-dried, and the Page model was used for prediction of drying kinetics of broccoli sprouts. It was observed that the drying time of BS decreased about twofold as the air-drying temperature increased from 40 to 80 °C. An increasing the air-drying temperature from 40 to 80 °C decreased the drying time by approximately twofold. Freeze-drying of sprouts took the longest drying time. Germination of seeds significantly decreased the value of grinding energy requirements, and the ground sprouts exhibited a different grinding pattern in comparison to ground non-germinated seeds. In terms of color parameters, the highest lightness and yellowness were found for freeze-dried sprouts. Redness and yellowness of sprouts increased with an increase in the air-drying temperature. The lowest total color difference was obtained for the freeze-dried sprouts. Higher drying temperature resulted in lower total phenolics content (TPC) and decreased antioxidant activity (AA). The highest TPC and AA were observed in air-dried sprouts (40 °C) and freeze-dried sprouts after 6 days of germination.