Low-temperature pretreatment (LTPT, Temp. < 100 °C or 140 °C) has the advantages of low input, simplicity, and energy saving, which makes engineering easy to use for improving biogas production. However, compared with high-temperature pretreatment (>150 °C) that can destroy recalcitrant polymerized matter in biomass, the action mechanism of heat treatment of biomass is unclear. Improving LTPT on biogas yield is often influenced by feedstock type, treatment temperature, exposure time, and fermentation conditions. Such as, even when belonging to the same algal biomass, the response to LTPT varies between species. Therefore, forming a unified method for LTPT to be applied in practice is difficult. This review focuses on the LTPT used in different biomass materials to improve anaerobic digestion performance, including food waste, sludge, animal manure, algae, straw, etc. It also discusses the challenge and cost issues faced during LTPT application according to the energy balance and proposes some proposals for economically promoting the implementation of LTPT.

Recycling and reusing the nutrient resources from anaerobic digested slurry is very promising for environmental pollution control and agriculture sustainable development. We focus here on nitrogen and phosphorus recycling in treating cattle manure anaerobic digested slurry by a magnesium ammonium phosphate (struvite-MAP) crystallization process and examine the impact of MAP precipitation on plant growth. The MAP crystallization process was studied by a combination of Design-Expert 8.0.6 software, mathematical modeling, and experiments. The influence of Mg/P, N/P and pH on nitrogen (N) and phosphorus (P) recovery was investigated. Then, the fertilizing efficiency of the MAP precipitate on the growth of three vegetables (water spinach (Swamp cabbage), amaranth and Brassica parachinensis) was also evaluated. The results showed that more than 89% of N and 99% of P could be recovered at pH = 10 with molar ratios of Mg/P = 1.6 and N/P = 1.2. Compared with the control pots and potassium chloridepots, the fresh weight, dry weight and average height of swamp cabbage in the MAP pots were obviously enhanced without burning effects. The results showed that MAP precipitation can promote the development of plants, which is promising for its use as a slow-release fertilizer for agricultural production.

Anaerobic digestate from cattle manure fermentation may pose a threat to the environment. How to stabilize the digestate’s characteristics so that they do not disturb the bio-system is a critical issue for digestate management. Chemically enhanced primary treatment (CEPT) was investigated as a pretreatment option for digestate treatment. The performance of CEPT for digestate management was carried out under rapid mixing (200 r/min) and slow stirring (40 r/min), respectively. The optimal dosage of ferric chloride (FeCl₃) was 40 mg/L. The combination of FeCl₃ and anionic polyacrylamide (APAM) had no obvious influence on TP removal, while COD removal efficiency was improved by 15.4%. The digestate pH and temperature remained stable for CEPT application and required no adjustment. The results indicate that CEPT was effective and feasible in enhancing the removal of COD and TP for digestate pretreatment by using FeCl₃ and APAM.