The cleaning process of coals is challenging due to the existence of clay minerals. The overall objective of this study is to investigate how the dewatering of coal slurry is impacted by the presence of clay minerals, i.e., kaolinite and montmorillonite. Filtration tests were first conducted to investigate the effect of kaolinite and montmorillonite on the dewatering efficiency of coal. Specifically, we measured the filtration velocity, moisture, average specific resistance, and porosity of filter cakes for six slurry samples, in which different amounts of kaolinite and montmorillonite were contained. Filtration tests show that a small amount of kaolinite and montmorillonite leads to a significant reduction in the filtration velocity and porosity, and a big increase in the average specific resistance and the moisture of the filter cake. We observe that most kaolinite existed in the top and middle layers of the filter cake, while most montmorillonite existed in the top layer; on the contrary, little montmorillonite is observed in the middle and bottom layers of the filter cake. Montmorillonite results in a much more deteriorative effect than kaolinite. Considering that the interactions between clay minerals and water may play a key role, we then further investigate the effect of such interactions using molecular simulations. Simulation results show that water molecules could hardly diffuse into kaolinite from the edge, while they could readily penetrate into the montmorillonite layers from the edge surface. This result can be explained by the hydrated cation in montmorillonite. The adsorption density of water on the octahedral surface of kaolinite is higher than that of water on the tetrahedral surface of kaolinite. Furthermore, the adsorption density of water on the double surfaces of kaolinite is higher than that of water on the montmorillonite surface. This research is expected to provide benefits or contributions to the dewatering of clay-rich coal tailings.

Montmorillonite is always a troublemaker for the dewatering in coal processing since its existence can decrease the rates of sedimentation and filtration of coal slurry. To eliminate the adverse effect of montmorillonite, adjusting the slurry pH and adding electrolytes are always the key methods. However, the underlying mechanism still needs to be further studied. The dewatering of Na-montmorillonite (Na-Mt) suspensions has been studied as a function of NaCl concentration (10⁻³, 10⁻², and 10⁻¹ M) at different pH values (6.0, 7.7, 8.1, 9.2). The point of zero charge of edge surface of Na-Mt (pH_PZC,edge) appeared at the pH value of 6.8. The sedimentation and rheology experiments described the coagulation and flow behaviors of Na-Mt suspensions, respectively. The Na-Mt suspension coagulated spontaneously at low salt concentration with the pH ~ 6.0. For the pH > pH_PZC,edge, the height of the sediment bed reduced and apparent viscosity increased with the increase of the electrolyte concentration. The filtration properties were evaluated on the basis of Darcy’s law. The obtained result clearly demonstrated that the filtration rate was accelerated with the increase of pH and electrolyte concentration. The modes of particle association and its effect on filtration performance were discussed. Moreover, a comparison with related results from the literature was performed. At pH ~ 6 and low electrolyte concentration, the positively charged Edge surfaces and negatively charged Face surfaces coagulate rapidly to form a sealed structure by electrostatic attraction. Furthermore, inside this sealed structure, the water molecules cannot be removed in the filtration process easily. However, by increasing the electrolyte concentration at pH > pH_PZC,edge, the gradually formed Face/Face structure increases the filtration rate sharply because of the inhibiting effect of the electric double layer (EDL) and the osmotic expansion. Therefore, adjusting solution conditions of the aqueous suspension to tune the particle coagulation behavior is one of the effective methods to solve the problem of montmorillonite dewatering.

In this study, the effect of surfactants and electrolytes on stability of kaolinite dispersions was analyzed by measuring suspension transmittance, zeta potential, and adsorption. It was experimentally found that the compression of kaolinite electric double layer caused by NaCl addition may reduce the electrostatic repulse force to facilitate the aggregation of kaolinite particles. Surfactant facilitate the aggregation of kaolinite particles mainly through the adsorption of it on the surface of kaolinite to generate hydrophobic force. Compared to anionic surfactant, the cationic surfactant has a better flocculation effect because it can be used in a wide pH range and its adsorption can reduce the electrostatic repulse force between kaolinite particles.