During a growout period of 14 weeks, the productive performance, organosomatic indices and body composition of the Nile tilapia Oreochromis niloticus cultivated at high density reusing the water from systems with biofloc technology (BFT) were evaluated. Two treatments: tilapia cultured in biofloc (TB) and tilapia cultured in reused water biofloc (RW) were established. Mixed sex, juvenile Nile tilapia (average weight and length: 79.28 ± 14.44 g and 12.44 ± 0.70 cm) were stocked into 6 experimental units (0.2 m³) at a density of 100 fish/m³. Temperature, dissolved oxygen, total dissolved salts, pH, NH₄–N, NH₃–N and NO₃–N were recorded daily, while NO₂–N, general hardness, carbonate hardness and settleable solids were recorded weekly. The weight and length of the tilapias were recorded biweekly. Survival, productive performance, proximal composition and organosomatic indices of Nile tilapia were evaluated. The water parameters in RW treatment such as pH, total dissolved salts, NO₂–N, NO₃–N and carbonate hardness were significantly greater (p < 0.05), when compared to those obtained in TB treatment. Survival rate was > 98% under both treatments. The final weight (TB = 163.09 ± 42.34 g, RW = 159.23 ± 39.92 g), protein (19.1%) and lipid (2.2%) content of the tilapia were non-significantly different between treatments. In addition, no significant differences in the gonadosomatic and hepatosomatic indices were observed either between tilapia sex or between the treatments. The results suggest that the intensive cultivation of Nile tilapia in biofloc can be established using reuse water from BFT systems, without adverse effects on their survival, productive performance, proximal composition and gonadal development.

The effect of a partial substitute of fish meal by biofloc meal on the growth and survival of fry Nile tilapia Oreochromis niloticus was evaluated over nine weeks. Two biofloc meals were obtained by drying them in two processes: A) sun exposure and B) convection oven. A randomized design of eight isonitrogenous (40%) and isoenergetic (17 kJ g-1) diets was used, where 5, 10, 15, and 20% of the fish meal was substituted for the two biofloc meals. The nutritional study was conducted in a recirculating aquaculture system with Nile tilapia fry (initial weight: 0.64 ± 0.16 g). The survival range was similar in all treatments and higher than 97%. Tilapia fed with the treatments A5, A10, B5, and B10 of substitution of biofloc meal showed similar and significantly better final weight, individual weight gain, specific growth rate, and condition factor than A15, A20, B15, and B20 treatments; as well as efficiency of use of the feed: protein efficiency ratio, carcass nitrogen deposition, apparent nitrogen utilization, and apparent digestibility. Therefore, these results suggest that biofloc meal is possible in diets for tilapia, thus reducing the need for fishmeal as the main source of protein in the diet.