Animal location technologies have evolved considerably in the last 60 years. Nowadays, animal tracking solutions based on global positioning systems (GPS) are commercially available. However, existing devices have several constraints, mostly related to wireless data transmission and financial cost, which make impractical the monitorization of all the animals in a herd. The main objective of this work is to develop a low-cost solution to enable the monitorization of a whole herd. An IoT-based system, which requires some animals of the herd being fitted with GPS collars connected to a Sigfox network and the rest with low-cost Bluetooth tags, has been developed. Its performance has been tested in two commercial farms, raising sheep and beef cattle, through the monitorization of 50 females in each case. Several collar/tag ratios, which define the cost per animal of the solution, have been simulated. Results demonstrate that a low collar/tag ratio enable the monitorization of a whole sheep herd. A larger ratio is needed for beef cows because of their grazing behavior. Nevertheless, the optimal ratio depends on the purpose of location data. Large variability has been observed for the number of hourly and daily messages from collars and tags. The system effectiveness for the monitorization of all the animals in a herd has been certainly proved.

The sustainability of agrosilvopastoral systems, e.g., dehesas, is threatened. It is necessary to deepen the knowledge of grazing and its environmental impact. Precision livestock farming (PLF) technologies pose an opportunity to monitor production practices and their effects, improving decision-making to avoid or reduce environmental damage. The objective of this study was to evaluate the potential of the data provided by commercial GPS collars, together with information about farm characteristics and weather conditions, to characterize the distribution of cattle dung in paddocks, paying special attention to the identification of hotspots with an excessive nutrient load. Seven animals were monitored with smart collars on a dehesa farm located in Cordoba, Spain. Dung deposition was recorded weekly in 90 sampling plots (78.5 m²) distributed throughout the paddock. Grazing behavior and animal distribution were analyzed in relation to several factors, such as terrain slope, insolation or distance to water. Animal presence in sampling plots, expressed as fix, trajectory segment or time counting, was regressed with dung distribution. Cattle showed a preference for flat terrain and areas close to water, with selection indices of 0.30 and 0.46, respectively. The accumulated animal presence during the experimental period explained between 51.9 and 55.4% of the variance of dung distribution, depending on the indicator used, but other factors, such as distance to water, canopy cover or ambient temperature, also had a significant effect on the spatiotemporal dynamics of dung deposition. Regression models, including GPS data, showed determination coefficients up to 82.8% and were able to detect hotspots of dung deposition. These results are the first step in developing a decision support tool aimed at managing the distribution of dung in pastures and its environmental effects.

This research was conducted using a spectral database comprising 346 samples of processed animal proteins (PAPs) with a range of compositions, analyzed using a Fourier transform near-infrared spectroscopy multichannel instrument (Matrix-F, Bruker Optics) coupled to a 100 m fiber optic cable. Using both its static and dynamic operating modes (on a conveyor belt), simulating the movement of the product in the plant, the predictive capabilities of both modes of analysis were assessed and compared, for the purposes of predicting moisture, protein, and ashes. The results show that both exhibit highly similar degrees of precision and accuracy for predicting these parameters. This research provides a foundation of scientific-technical knowledge, hitherto unknown, regarding the “on-line” incorporation of an instrument (equipped with a 100 m fiber optic cable) into a processing plant of by-products of animal origin.

Dystocia is one of the main causes of calf death around calving. In addition, peripartum deaths may occur due to other factors, such as weather or predators, especially in the case of grazing animals. Precision Livestock Farming (PLF) tools aimed at the automatic detection of calving may be useful for farmers, allowing cow assistance in case of dystocia or checking the condition of the cow-calf pair after calving. Such PLF systems are commercially available for dairy cows, but these tools are not suitable for rangelands, mainly due to power and connectivity constraints. Thus, since most commercial PLF tools for rangelands are based on Global Navigate Satellite System (GNSS) technology, the objective of this study was to design and evaluate several indicators built from data gathered with GNSS collars to characterise their potential for the detection of calving on rangelands. Location data from 57 cows, 42 of which calved during the study, were curated and analysed following a standardised procedure. Several indicators were calculated using two different strategies. The first approach consisted of having indicators that could be computed using the data of a single GNSS collar (cow indicators). The second strategy involved the use of data from several animals (herd indicators), which requires more animals to be monitored, but may allow the characterisation of social behaviour. Several indicators, such as the length of the daily trajectory or the sinuosity of cow path, showed significant differences between the pre- and postpartum periods, but no clear differences between calving day and previous days. Herd indicators, such as the distance to herd centroid or to the nearest peer were superior in terms of the detection of calving day, as cows showed isolation behaviour from 24 hours before calving. Relative indicators, i.e., the value of cow or herd indicators for the calving cow in relation to the average value of the same indicators for its herdmates, provided additional information on cow behaviour. For instance, according to the relative indicator for the change in daily trajectory, pregnant cows had a differential exploratory behaviour up to 14 days before calving. In conclusion, data from commercial GNSS collars proved to be useful for the computation of several indicators related to the occurrence of calving on rangelands. Some of those indicators showed changes from baseline values on the day before calving, which could serve to predict the onset of parturition.

In this Research Communication we analyse the animal welfare status of dairy farms located in southern Spain and test the hypothesis that monitoring of wellbeing could increase the profitability of dairy herds by improving indices of reproduction. Twenty dairy farms were visited and a total of 1650 cows were assessed using the Welfare Quality® (WQ) protocol to determine their welfare status. These farms were selected as representatives of the main types of dairy farms found in the south of Spain. No farms attained a welfare status of ‘excellent’, but all obtained an adequate score for most parameters. Feeding assessment showed relatively low variability among farms, whereas housing and health assessments exhibited high variability. Significant correlations were found between a number of welfare parameter pairings: between percentage of collisions and time needed to lie down; between cleanliness of water points and cleanliness of various animal parts; between farms with access to an outdoor loafing area and an inadequate body condition score and with animal cleanliness; between the frequency of animals lying partly or completely outside of the lying area and the percentage of integument alterations and finally between the presence of respiratory problems and farm hygiene parameters. Furthermore, significant correlations between welfare parameters, reproductive indices and milk production were found. The percentage of cows exhibiting an inadequate body condition score and farms where cows took longer to lie down were correlated with the calving-first insemination interval. Animals showing a higher incidence of coughing and hampered respiration presented lower heat detection rates and milk production and finally farms with dirtier animals had lower milk production. This study is the first step towards including welfare in the recording of routine data in dairy cattle farms in southern Spain.