The increase in industry and population, together with the need for wastewater reuse, makes it necessary to implement new technologies in the circular economy framework. The aim of this research was to evaluate the quality of the effluent of an algae membrane photobioreactor for the treatment of the effluent of an urban wastewater treatment plant, to characterise the ultrafiltration membranes, to study the effectiveness of a proposed cleaning protocol, and to analyse the performance of the photobioreactor. The photobioreactor operated under two days of hydraulic retention times feed with the effluent from the Los Vados wastewater treatment plant (WWTP) (Granada, Spain). The microalgae community in the photobioreactor grew according to the pseudo-second-order model. The effluent obtained could be reused for different uses of diverse quality with the removal of total nitrogen and phosphorus of 56.3% and 64.27%, respectively. The fouling of the polyvinylidene difluoride ultrafiltration membrane after 80 days of operation was slight, increasing the total membrane resistance by approximately 22%. Moreover, the higher temperature of the medium was, the lower intrinsic resistance of the membrane. A total of 100% recovery of the membrane was obtained in the two-phase cleaning protocol, with 42% and 58%, respectively.

Waste stabilization ponds and constructed wetlands (CWs) are effective at eliminating pharmaceutical residues, but removals are not usually complete. Their combination is regarded as an efficient, robust wastewater treatment method, but their efficiency in the removal of pharmaceuticals and the effect of a mild effluent recirculation has not been sufficiently studied in full-scale systems. Effluent recirculation can help to improve performance by increasing hydraulic residence time and, eventually, dissolved oxygen concentration. In this work, the presence of pharmaceuticals in wastewater from a university campus, their removal in a macrophyte pond–CW system, and the effect of effluent recirculation on removal and ecological risk were evaluated. Stimulants (caffeine and nicotine) and non-steroidal anti-inflammatories (naproxen and ibuprofen) were the most detected compounds in the influent and showed the highest concentrations, ranging from 0.5 to 300 µg·L⁻¹. The pond–CW combination showed notable elimination for these compounds, achieving 87% on average. The ecological risk was also reduced by between 5.5 and 12.4 times, but it was still over values that indicates high ecological risk, mainly because of the concentrations of nicotine and ibuprofen. The effect of effluent recirculation was not as high as expected since the removals of caffeine, paraxanthine and naproxen were significantly improved, but those of atenolol and ibuprofen were lower. These results suggest that a higher recirculation ratio should be tested.

The European Union, as delineated in Regulation (EU) 2020/741, sets forth minimum criteria for the reuse of wastewater. Directive 86/278/CEE sets the regulations for the reuse of sewage sludge in agriculture. This study aimed to investigate the treated water derived from a pilot plant situated in Granada, Spain, that utilizes membrane bioreactor technology to process real urban wastewater with the quality standards necessary for agricultural reuse. Additionally, the study evaluated the utilization potential of other resources generated during wastewater treatment, including biogas and biostabilized sludge. The pilot plant incorporated a membrane bioreactor featuring four ultrafiltration membranes operating continuously alongside a sludge treatment line operating in batch mode. The pilot plant operated during four cycles, each with distinct hydraulic retention times (6 h and 12 h) and variable mixed liquor-suspended solids concentrations (ranging from 2688 mg L^-1 to 7542 mg L^-1). During these cycles, the plant was doped with increasing concentrations of emerging contamination compounds (diclofenac, ibuprofen, and erythromycin) to test their effect on the resources derived from the treatment. Subsequently, a tertiary treatment involving an advanced oxidation process was applied to the different water lines, which left the wastewater treatment plant for a period of 30 min and utilized varying concentrations of oxidant. The results indicate that the effluent obtained meets the required quality standards for agricultural use. Therefore, there is potential to use this waste as a resource, which is in line with the principles of the circular economy. Furthermore, the other resources generated during the treatment process, such as the biogas produced during the digestion process and the biostabilized sludge, have the potential to be used as resources according to the circular economy indicators.

Currently, there is a growing concern about water scarcity. The rising demand for wastewater treatment systems that facilitate the reuse of wastewater has resulted in a focus on the use of microalgae in sustainable treatments. These methods not only eliminate nutrients from the wastewater but also produce biomass that can be used to obtain high-value products. This study aimed to observe the effect of different hydraulic retention times (HRTs) and treated urban wastewater (TUWW) percentages on the growth of microalgae biomass and nutrient consumption in membrane photobioreactors. Microalgae biomass growth increases with HRT regardless of the percentage of TUWW. Biomass concentration stabilises at between 40% and 60% TUWW but significantly increases when 100% TUWW is used, resulting in the highest biomass concentrations. As HRT increases, ammonium and total nitrogen consumption also rise. A positive trend in ammonium consumption was observed with increasing TUWW, reaching its peak with 100% TUWW. The optimal conditions for biomass growth and nutrient removal are achieved with a 7-day HRT and 100% TUWW as influent, which was confirmed as optimal with the response surface methodology.

The increasing prevalence of pharmaceutical substances in wastewater is emerging as a pressing ecological issue on a global scale. The purpose of this study was to evaluate the biological influence of pharmaceutical compounds on the heterotrophic biomass residing in a membrane bioreactor. The study examined the way microorganisms react to antibiotic and anti-inflammatory compounds, with the goal of proactively tackling potential issues and developing solutions that may emerge withing wastewater treatment plant bioreactors. Respirometric tests were carried out to determine the kinetic response of the heterotrophic biomass. The same study was carried out in the steady state of the plant under different conditions of hydraulic retention times (6 and 12 h) and biomass concentration (2888 ± 371 mg/L to 7477 ± 869 mg/L). A response surface statistical analysis was applied to determine the effect of the variables on the rate of substrate degradation for organic matter removal and the growth rate of net heterotrophic biomass. The results show that the biological response of the biomass is concerned when exposed to a combination of pharmaceutical substances such as ibuprofen, diclofenac, and erythromycin, in four cycles of operation at 16 varying concentrations of pharmaceuticals in each cycle. This suggests the presence of a synergistic effect among these pharmaceuticals, leading to a noticeable slower kinetic response in the biomass.