Supercritical fluid extraction (SFE) is an innovative, clean and environmental friendly technology with particular interest for the extraction of essential oil from plants and herbs. Supercritical CO(2) is selective, there is no associated waste treatment of a toxic solvent, and extraction times are moderate. Further, supercritical extracts were often recognized of superior quality when compared with those produced by hydro-distillation or liquid-solid extraction. This review provides a comprehensive and updated discussion of the developments and applications of SFE in the isolation of essential oils from plant matrices. SFE is normally performed with pure CO(2) or using a cosolvent; fractionation of the extract is commonly accomplished in order to isolate the volatile oil compounds from other co-extracted substances. In this review the effect of pressure, temperature and cosolvent on the extraction and fractionation procedure is discussed. Additionally, a comparison of the extraction yield and composition of the essential oil of several plants and herbs from Lamiaceae family, namely oregano, sage, thyme, rosemary, basil, marjoram and marigold, which were produced in our supercritical pilot-plant device, is presented and discussed.

The efficient production of saponin-rich extracts is of increasing interest due to the bioactive properties that have being demonstrated for these compounds. However, saponins have a poor bioavailability. In this respect, the knowledge about the bioaccessibility of saponins as a first step before bioavailability has been scarcely explored. In this study, the production of ultrasound-assisted extracts of saponins from edible seeds (quinoa, soybean, red lentil, fenugreek and lupin) was carried out with ethanol, ethanol:water or water. Extraction yield, total saponin (TSC), fat and total phenolics content (TPC) were determined. Then, the bioaccessibility of saponins after the in vitro gastrointestinal digestion of the extracts was determined and the effect of TPC and fat in the extracts on bioaccessibility was evaluated. The highest saponin-rich extracts were obtained by ethanol, being fenugreek and red lentil the richest extracts (12% and 10%, respectively). Saponins from ethanol:water extracts displayed variable bioaccessibility (from 13% for fenugreek to 83% for lentil), but a bioaccessibility closer to 100% was reached for all ethanol extracts. Correlation studies showed that TPC of the extracts negatively affected the bioaccessibility of saponins, whereas fat of the extracts enhanced this parameter. As summary, ultrasound-assisted extraction is shown as an efficient method for obtaining saponin-rich extracts from edible seeds, being ethanol the most advantageous solvent due to the richness of saponins and the successful bioaccessibility from these extracts, likely caused by the co-extracted fat with ethanol. Regardless of the extracts, phenolic compounds or fat may hinder or enhance the bioaccessibility of saponins, respectively. Additionally, an adequate balance between saponins to lipids has shown to be relevant on such an effect.

Marine organisms are potentially prolific sources of high qualify fatty acids that represent useful leads in the development of new nutraceutical agents. In this work, we investigated the lipid composition of six algae species from the Northwest of Spain (Ulva intestinalis, Ulva lactuca, Fucus vesiculosus, Dictyota dichotoma, Cystoseira baccata and Himanthalia elongata) and compared the antioxidant and antibacterial activity of ethanolic extracts obtained by pressurized liquid extraction (PLE). Furthermore, Fucus vesiculosus (F. vesiculosus) PLE using five solvents of different polarities (hexane, ethyl acetate, acetone, ethanol and ethanol:water 50:50) at three temperatures (80 °C, 120 °C and 160 °C) was investigated. F. vesiculosus ethanolic PLE extract presents considerably higher capacity of inhibiting 50% of DPPH (1,1-diphenyl-2-picryl hydrazyl) (IC₅₀ = 7.17 μg/mL) in comparison with the rest of macroalgae studied. Moreover, the potential antimicrobial activity tested on E. coli and S. aureus shows that F. vesiculosus extract produced the best inhibition (IC₅₀ was 2.24 mg/mL (E. coli) and 1.27 mg/mL (S. aureus)). Furthermore, regarding the different solvents and temperatures used to investigate F. vesiculosus PLE, results showed that this technique using ethyl acetate is a selective method to enrich long chain fatty acids (oleic acid, arachidonic acid and eicosapentaenoic acid) with ω-6/ω-3 ratios close to 2.7.