Heat (85 °C for 20 min) and pressure (600 MPa for 15 min) treatments were applied to skim milk fortified by addition of whey protein concentrate. Both treatments caused > 90% denaturation of β-lactoglobulin. During heat treatment this denaturation took place in the presence of intact casein micelles; during pressure treatment it occurred while the micelles were in a highly dissociated state. As a result micelle structure and the distribution of β-lactoglobulin were different in the two milks. Electron microscopy and immunolabelling techniques were used to examine the milks after processing and during their transition to yogurt gels. The disruption of micelles by high pressure caused a significant change in the appearance of the milk which was quantified by measurement of the colour values L*, a* and b*. Heat treatment also affected these characteristics. Casein micelles are dynamic structures, influenced by changes to their environment. This was clearly demonstrated by the transition from the clusters of small irregularly shaped micelle fragments present in cold pressure-treated milk to round, separate and compact micelles formed on warming the milk to 43 °C. The effect of this transition was observed as significant changes in the colour indicators. During yogurt gel formation, further changes in micelle structure, occurring in both pressure and heat-treated samples, resulted in a convergence of colour values. However, the microstructure of the gels and their rheological properties were very different. Pressure-treated milk yogurt had a much higher storage modulus but yielded more readily to large deformation than the heated milk yogurt. These changes in micelle structure during processing and yogurt preparation are discussed in terms of a recently published micelle model.

The objective of this work was to study high hydrostatic pressure (HHP) inactivation of spores of Bacillus cereus ATCC 9139 inoculated in model cheeses made of raw milk, together with the effects of the addition of nisin or lysozyme. The concentration of spores in model cheeses was approximately 6-log10 cfu/g of cheese. Cheeses were vacuum packed and stored at 8 degrees C. All samples except controls were submitted to a germination cycle of 60 MPa at 30 degrees C for 210 min, to a vegetative cells destruction cycle of 300 or 400 MPa at 30 degrees C for 15 min, or to both treatments. Bacillus cereus counts were measured 24 h and 15 d after HHP treatment. The combination of both cycles improved the efficiency of the whole treatment. When the second pressure-cycle was of 400 MPa, the highest inactivation (2.4 +/- 0.1 log10 cfu/g) was obtained with the presence of nisin (1.56 mg/L of milk), whereas lysozyme (22.4 mg/L of milk) did not increase sensitivity of the spores to HHP. For nisin (0.05 and 1.56 mg/L of milk), no significant differences were found between counts at 24 h and 15 d after treatment. Considering that mesophilic spore counts usually range from 2.6 to 3.0 log10 cfu/ml in raw milk, HHP at mild temperatures with the addition of nisin may be useful for improving safety and preservation of soft curd cheeses made from raw milk.