Endotoxins are part of the cell wall of Gram-negative bacteria. They are potent immune stimulators and can lead to death if present in high concentrations. Feed additives, which bind endotoxins in the gastrointestinal tract of animals, could help to prevent their negative impact. The objective of our study was to determine the potential of a bentonite (Bentonite 1), a sodium bentonite (Bentonite 2), a chemically treated smectite (Organoclay 1) and a modified attapulgite (Organoclay 2) to bind endotoxins in vitro. Polymyxin B served as positive control. The kinetic chromogenic Limulus Amebocyte lysate test was adapted to measure endotoxin activity. Firstly, a single sorption experiment (10 endotoxin units/mL (EU/mL)) was performed. Polymyxin B and organoclays showed 100% binding efficiency. Secondly, the adsorption efficiency of sorbents in aqueous solution with increasing endotoxin concentrations (2,450 - 51,700 EU/mL) was investigated. Organoclay 1 (0.1%) showed a good binding efficiency in aqueous solution (average 81%), whereas Bentonite 1 (0.1%) obtained a lower binding efficiency (21-54%). The following absorbent capacities were calculated in highest endotoxin concentration: 5.59 mg/g (Organoclay 1) > 3.97 mg/g (Polymyxin B) > 2.58mg/g (Organoclay 2) > 1.55 mg/g (Bentonite 1) > 1.23 mg/g (Bentonite 2). Thirdly, a sorption experiment in artificial intestinal fluid was conducted. Especially for organoclays, which are known to be unspecific adsorbents, the endotoxin binding capacity was significantly reduced. In contrast, Bentonite 1 showed comparable results in artificial intestinal fluid and aqueous solution. Based on the results of this in vitro study, the effect of promising clay minerals will be investigated in in vivo trials.

Forages are important components of dairy cattle rations but might harbor a plethora of mycotoxins. Ruminants are considered to be less susceptible to the adverse health effects of mycotoxins, mainly because the ruminal microflora degrades certain mycotoxins. Yet, impairment of the ruminal degradation capacity or high ruminal stability of toxins can entail that the intestinal epithelium is exposed to significant mycotoxin amounts. The aims of our study were to assess (i) the mycotoxin occurrence in maize silage and (ii) the cytotoxicity of relevant mycotoxins on bovine intestinal cells. In total, 158 maize silage samples were collected from European dairy cattle farms. LC-MS/MS-based analysis of 61 mycotoxins revealed the presence of emerging mycotoxins (e.g., emodin, culmorin, enniatin B1, enniatin B, and beauvericin) in more than 70% of samples. Among the regulated mycotoxins, deoxynivalenol and zearalenone were most frequently detected (67.7%). Overall, 87% of maize silages contained more than five mycotoxins. Using an in vitro model with calf small intestinal epithelial cells B, the cytotoxicity of deoxynivalenol, nivalenol, fumonisin B1 and enniatin B was evaluated (0–200 µM). Absolute IC50 values varied in dependence of employed assay and were 1.2–3.6 µM, 0.8–1.0 µM, 8.6–18.3 µM, and 4.0–6.7 µM for deoxynivalenol, nivalenol, fumonisin B1, and enniatin B, respectively. Results highlight the potential relevance of mycotoxins for bovine gut health, a previously neglected target in ruminants.

The feeding of concentrate-rich diets may lead to microbial imbalances and dysfermentation in the rumen. The main objective of this study was to determine the effects of supplementing phytogenic compounds (PHY) or autolyzed yeast (AY) on rumen fermentation and microbial abundance in cows intermittently fed concentrate-rich diets. The experiment was carried out as an incomplete 3 × 4 Latin square design, with 8 nonlactating rumen-fistulated Holstein-Friesian cows. The cows were randomly assigned to a concentrate diet that was either not supplemented (CON), or supplemented with PHY or AY. Each of the 4 consecutive experimental periods was composed of a 1-wk roughage-only diet (RD), 6-d gradual concentrate increase, followed by 1 wk of 65% concentrate (dry matter basis; Conc I), and 1 wk of RD and a final 2-wk 65% concentrate (dry matter basis; Conc II) phase. Digesta samples were collected from the rumen mat for bacterial 16S rRNA gene Illumina MiSeq (Illumina, Balgach, Switzerland) sequencing, and samples of particle-associated rumen liquid were obtained for measuring short-chain fatty acids, lactate, ammonia, and pH during RD (d 6), Conc I (d 19), and Conc II (d 39). The concentrate feeding caused a decrease of overall bacterial diversity indices, especially during Conc I. The genera Ruminococcus, Butyrivibrio, and Coprococcus were decreased, whereas Prevotella, Megasphaera, Lachnospira, and Bacteroides were increased in abundance. Supplementation of both feed additives increased the abundance of gram-positive and decreased that of gram-negative bacteria. Supplementation of AY enhanced cellulolytic bacteria such as Ruminococcus spp., whereas PHY decreased starch and sugar fermenters including Bacteroides spp., Shuttleworthia spp., and Syntrophococcus spp. Moreover, PHY supplementation increased butyrate percentage in the rumen in both concentrate phases. In conclusion, intermittent high-concentrate feeding altered the digesta-associated rumen bacterial community and rumen fermentation with more significant alterations found in Conc I than in Conc II. The data also showed that both feed additives had the most significant modulatory effects on the bacterial community, and their subsequent fermentation, during periods of low pH.

Heat stress negatively affects performance and intestinal integrity of pigs. The objective of this study was to characterize the effects of diurnal heat stress (dHS) on nursery-grower pig performance, intestinal integrity, and lipopolysaccharide (LPS) translocation. Forty-eight nursery-grower gilts, individually penned, were randomly assigned to two treatments. Twenty-four pigs were then exposed to dHS for 3 d, 6 h at 38°C and 18 h at 32°C, at 40–60% humidity. The remaining pigs were maintained under thermal neutral (TN) conditions. Changes in pig rectal temperatures (Tr), respiration rates (RR), performance, and blood parameters were evaluated. Additionally, ex vivo ileum integrity was assessed with the Ussing chamber by measuring transepithelial resistance (TER), and 4 kDa fluorescein isothiocyanate (FITC)–dextran (FD4) and FITC–LPS mucosal to serosal flux. As expected, dHS increased pig Tr and RR (P < 0.05) and reduced pig performance (P < 0.05) on the 3-d period. Compared with TN, ileum TER (P = 0.04), FITC–LPS (P < 0.001), and FD4 (P = 0.011) permeability were significantly increased due to dHS. Compared with TN pigs, dHS increased serum endotoxin by 150% (P = 0.031). Altogether, 3-d dHS significantly reduced pig performance and intestinal integrity and increased blood endotoxin concentrations.

The mycotoxin deoxynivalenol (DON) contaminates agricultural commodities worldwide, posing health threats to humans and animals. Associated with DON are derivatives, such as deepoxy-deoxynivalenol (DOM-1), produced by enzymatic transformation of certain intestinal bacteria, which are naturally occurring or applied as feed additives. Using differentiated porcine intestinal epithelial cells (IPEC-J2), we provide the first multi-parameter comparative cytotoxicity analysis of DON and DOM-1, based on the parallel evaluation of lysosomal activity, total protein content, membrane integrity, mitochondrial metabolism and ATP synthesis. The study investigated the ability of DON and—for the first time of its metabolite DOM-1—to induce apoptosis, mitogen-activated protein kinase (MAPK) signalling, oxidative events and alterations of mitochondrial structure in porcine intestinal epithelial cells (IECs). The degree of DON toxicity strongly varied, depending on the cytotoxicity parameter evaluated. DON compromised viability according to the parameters of lysosomal activity, total protein content and membrane integrity, but increased viability according to assays based on mitochondrial metabolism and ATP synthesis. DON induced expression of cleaved caspase-3 (maximum induction 3.9-fold) and MAPK p38 and p42/p44 (maximum induction 2.51- and 2.30-fold, respectively). DON altered mitochondrial morphology, but did not increase intracellular ROS. DOM-1-treated IPEC-J2 remained unaffected at equimolar concentrations in all assays, thereby confirming the safety of feed additives using DON- to DOM-1-transforming bacteria. The study additionally highlights that an extensive multi-parameter analysis significantly contributes to the quality of in vitro data.