This study explores the use of essential oils from cardamom (Elettaria cardamomum (L.) Maton) and galangal (Alpinia galanga (L.) Willd) as alternatives to synthetic insecticides for controlling the red flour beetle, Tribolium castaneum (Herbst). The chemical compositions of these oils were analyzed using GC-MS, and their fumigation effects were tested in a vapor-phase bioassay. The experiment followed a factorial design with four types of essential oils, namely, those manually extracted from cardamom leaves (MCL) and galangal leaves (MGL) and those commercially produced from cardamom seeds (CCS) and galangal rhizomes (CGR), at seven concentrations (0, 50, 100, 150, 200, 250, and 300 µL/L air). The manually extracted oils yielded 0.6% from cardamom leaves and 0.25% from galangal leaves. MCL contained 28 components, with eucalyptol (25.2%) being the most abundant, while CCS had 34 components, primarily α-terpinyl acetate (46.1%) and eucalyptol (31.2%). MGL included 25 components, mainly caryophyllene (28.7%) and aciphyllene (18.3%), whereas CGR comprised 27 components, with methyl cis-cinnamate (47.3%) and safrole (19.8%) as the major constituents. The fumigation bioassay results revealed that CGR was the most effective, demonstrating the highest mortality rates of T. castaneum across all the tested periods and concentrations, achieving up to 96% mortality at 168 h with a concentration of 300 µL/L air. Statistical analyses showed significant differences in mortality based on the type and concentration of essential oil, particularly after 96 h. These findings highlight the potential of CGR, with its advantages and differences in chemical composition, as an effective biopesticide against T. castaneum, with increasing efficacy over time and at higher concentrations.

Third instar larvae of the cotton bollworm (Helicoverpa armigera) were reared with artificial diet containing a Bacillus thuringiensis - abamectin (BtA) biopesticide mixture that resulted in 20% mortality (LD₂₀). The adult male survivors from larvae treated with BtA exhibited a higher percentage of “orientation” than control males but lower percentages of “approaching” and “landing” in wind tunnel bioassays. Adult female survivors from larvae treated with BtA produced higher sex pheromone titers and displayed a lower calling percentage than control females. The ratio of Z-11-hexadecenal (Z11–16:Ald) and Z-9-hexadecenal (Z9–16:Ald) in BtA-treated females changed and coefficients of variation (CV) of Z11–16:Ald and Z9–16:Ald were expanded compared to control females. The peak circadian calling time of BtA-treated females occurred later than that of control females. In mating choice experiment, both control males and BtA-treated males preferred to mate with control females and a portion of the Bt-A treated males did not mate whereas all control males did. Our Data support that treatment of larvae with BtA had an effect on the sex pheromone communication system in surviving H.armigera moths that may contribute to assortative mating.

The use of essential oils from certain herbal plants offers a promising alternative to synthetic insecticides for controlling the maize weevil, Sitophilus zeamais Motschulsky (Coleoptera: Dryophthoridae), a major pest that causes significant damage to stored grains. Essential oils, particularly from aromatic herbs in the Apiaceae family, are widely used in medicinal, cosmetic, and food industries and provided insecticidal properties to mitigate the environmental and health hazards associated with synthetic insecticides. This research aimed to investigate the insecticidal and repellent effects of Apium graveolens L. (celery) seed essential oil against S. zeamais. Chemical analysis of the commercially produced essential oil from A. graveolens seeds was conducted using a gas chromatograph–mass spectrometer (GC-MS), and the biological activity of the essential oil was determined by ingestion, contact, fumigation, and repellent tests. The analysis identified D-limonene (64.21%) and α-humulene (17.46%) as primary components of the oil. Toxicity assays revealed an observable contact toxicity, with higher concentrations and prolonged exposure increasing its effectiveness. The contact toxicity assays reported an LC₅₀ of 19.83 nL/adult after 72 h. Additionally, the essential oil displayed repellent effects, effectively deterring weevils at concentrations above 16 µL/L air, but its feeding deterrence was weak. The essential oil’s strong insecticidal and repellent properties, which were concentration- and time-dependent, highlighted its potential as a sustainable alternative to synthetic pesticides for integrated pest management.

Essential oils of plants with insecticidal properties have been considered as replacements for synthetic chemical pesticides to combat and control insect pests. The chemical composition of the essential oil from dried seeds of Zanthoxylum limonella Alston was determined by the Gas Chromatograph-Mass Spectrometry technique. Insecticidal activity was investigated on Tribolium castaneum Herbst using impregnated filter paper with six concentrations of essential oil at 0, 1, 2, 3, 4, and 5% for adults and larvae mortality tests, and 0, 2, 4, 6, 8 and 10% for egg mortality. All experiments were performed under completely randomized design (CRD) with four replications at 30±5°C and 70±5% relative humidity in 16:8 hours light/dark cycle. A total of 83 components were identified. The principal compounds in the essential oil of Z. limonella were beta-pinene (19.65%), 9-octadecanone (18.80%), D-limonene (9.76%), alpha-fenchene (8.48%), p-mentha-1,5,8-triene (7.16%), 1,8-cineole (6.88%), gamma-terpinene (5.46%), terpinen-4-ol (3.81%), linalool (2.73%), alpha-thujene (1.34%), decanal (1.32%), alpha-phellandrene (1.20%) and linalyl propionate (1.13%). Insecticidal activity presented that 5% of essential oil had the highest effect against T. castaneum at 120 h for adults and 48 h for larvae, while 10% of essential oil at 14 days obtained 100% mortality against eggs of T. castaneum. Results indicated that the essential oil of Z. limonella from dried seeds showed potential for use in the control of T. castaneum