With the objective of developing a rational approach for the selection of feed enzymes for ruminants, 22 commercial enzyme products were examined in terms of protein concentration, enzymic activities on model substrates, and hydrolytic capacity, the latter determined from the release of reducing sugars from alfalfa hay and corn silage. An in vitro ruminal degradation assessment was carried out using the same substrates, untreated or treated with the 22 enzyme products at 1.5 μL/g forage DM. Stepwise regressions were then performed to establish relationships between these factors. Protein concentration and enzymic activities explained at least 84% (P < 0.01) of the variation in the release of reducing sugars from alfalfa and corn silage. Alfalfa DM degradation after incubation with ruminal fluid for 18 h was positively related to xylanase activity (R² = 0.29, P < 0.01), but the same activity was negatively related to DM degradation of corn silage (R² = 0.19, P < 0.05). Protease activity explained a further 10% of the alfalfa DM degradation (P < 0.10). Following sequential steps involving the determination of rate and extent of DM and fiber degradation, the best candidates for alfalfa and corn silage were selected. Enzyme products effective with alfalfa hay seemed to exert part of their effect during the pretreatment period, whereas enzymes effective with corn silage worked exclusively after ruminal fluid was added. This finding suggests that different modes of action of exogenous enzymes are attacking different substrates and may partly explain enzyme-feed specificity. In alfalfa, it seems that effective enzymes work by removing structural barriers that retard the microbial colonization of digestible fractions, increasing the rate of degradation. In corn silage, effective enzymes seem to interact with ruminal enzymes to degrade the forage more rapidly, which is consistent with previous findings of synergism between exogenous and ruminal enzymes.

A dual-flow continuous culture system was used to investigate the effects of pH and addition of an enzyme mixture to a total mixed ration (TMR) on fermentation, nutrient digestion, and microbial protein synthesis. A 4 × 4 Latin square design with a factorial arrangement of treatments was used, with four 9-d periods consisting of 6 d for adaptation and 3 d for measurements. Treatments were as follows: 1) high pH with control TMR, 2) high pH with TMR treated with enzyme, 3) low pH with control TMR, and 4) low pH with TMR treated with enzyme. Ranges of pH were 6.0 to 6.6 and 5.4 to 6.0 for high and low, respectively. Fermenters were fed twice daily a TMR consisting of 30% alfalfa hay, 30% corn silage, and 40% rolled corn (DM basis). The silage was milled fresh and the TMR was fed to the fermenters in fresh form (64% DM). The enzyme mixture was a commercial product of almost exclusive protease activity; it was applied daily to the fresh TMR and stored at 4°C for at least 12 h before feeding. Degradability of OM, NDF, ADF, and cellulose was decreased (P < 0.05) by low pH. Hemicellulose and protein degradation were not affected by pH. Enzyme addition increased (P < 0.01) NDF degradability (by 43% and 25% at high and low pH, respectively), largely as a result of an increase in hemicellulose degradation (by 79% and 51% at high and low pH, respectively). This improvement was supported by an increase (P < 0.05) in the xylanase and cellulase activities in the liquid phase of the fermenter contents. Total VFA were decreased (P < 0.05) by low pH, but were not affected by enzyme addition. Total bacterial numbers were increased (P < 0.03) at low pH and tended (P < 0.13) to increase with enzyme addition. Cellulolytic bacteria in effluent fluid were decreased (P < 0.02) at low pH but were unaffected by enzyme addition. Despite a large increase (P < 0.001) in protease activity, protein degradation was only numerically increased by enzyme addition. Microbial protein synthesis was higher (P < 0.10) at high pH but was not affected by enzyme addition. Methane production, expressed as a proportion of total gases, was decreased (P < 0.001) at low pH but was not affected by enzyme addition. It is concluded that it is possible to adapt the continuous culture system to use fresh feeds instead of dried feeds. Overall, the results indicate that the enzyme product used in this study has a potential to increase fiber degradability without increasing methane production.

There is interest in identifying natural products capable of manipulating rumen microbial activity to develop new feed additives for ruminant nutrition as a strategy to reduce methane. Two trials were performed using the in vitro gas production technique to evaluate the interaction of substrate (n = 5) and additive (n = 6, increasing doses: 0, 0.3, 3, 30, and 300 µL/L of essential oils—EO—of Lippia turbinata or Tagetes minuta, and monensin at 1.87 mg/L). The two EO utilized were selected because they differ markedly in their chemical composition, especially in the proportion of oxygenated compounds. For both EO, the interaction between the substrate and additive was significant for all variables; however, the interaction behaved differently for the two EO. Within each substrate, the response was dose-dependent, without effects at a low level of EO and a negative outcome at the highest dose. The intermediate dose (30 µL/L) inhibited methane with a slight reduction on substrate digestibility, with L. turbinata being more effective than T. minuta. It is concluded that the effectiveness of the EO to reduce methane production depends on interactions between the substrate that is fermented and the additive dose that generates different characteristics within the incubation medium (e.g., pH); and thus, the chemical nature of the compounds of the EO modulates the magnitude of this response.

In the last decades, individual animal production increased dramatically as consequence of several improvements related to management, genetics, nutrition and health, among others. From a biological point of view, the increase in efficiency and production is a huge challenge that, under some circumstances, can negatively affect animal health and consequently animal well-being and production. Immunometabolism, defined as an interplay between immunological and metabolic processes ( Mathis and Shoelsen, 2011), is an emerging field of research that may help animal scientists to better understand the link between production and health. In other words, immunometabolism studies how nutrients modulate the immune response.

This work aimed to evaluate the effects of dietary phytic acid on the enzymatic activities of the hepatopancreas of the redclaw crayfish, Cherax quadricarinatus. For this purpose, a completely randomized in vitro trial was conducted with three phytic acid levels (0.56, 1.68, and 2.80%) and three phytase doses (0, 250, and 500 PU/kg DM). Solubilized protein, reducing sugars, and soluble phosphorus showed significant responses to the interaction between phytic acid and phytase . Only the main effects were detected on the released amino acids, in keeping with the main effects of alkaline protease activity, which are negatively affected by phytic acid and improved by phytase inclusion . Differences in released reducing sugars were attributed to a reduction in amylase activity by increased levels of phytic acid and not to cellulase activity, where only a negative trend of phytic acid was found . Phytic acid depresses calcium availability, which would explain the decrease in amylase activity. A 500 PU/kg DM dose improved amino acid, reduced sugars, and phosphorus release. These in vitro results might have in vivo implications for the digestibility of proteins, minerals, and energy. Further investigations are required to determine the chelated calcium effect on redclaw amylase activity, molting, and survival.