The mycotoxin fumonisin B₁ (FB₁) is a frequent contaminant of feed and causes various adverse health effects in domestic animals. Hence, effective strategies are needed to prevent the impact of fumonisins on livestock productivity. Here we evaluated the capability of the fumonisin carboxylesterase FumD to degrade FB₁ to its less toxic metabolite hydrolyzed FB₁ (HFB₁) in the gastrointestinal tract of turkeys and pigs. First, an ex vivo pig model was used to examine the activity of FumD under digestive conditions. Within 2 h of incubation with FumD, FB₁ was completely degraded to HFB₁ in the duodenum and jejunum, respectively. To test the efficacy of the commercial application of FumD (FUMzyme) in vivo, female turkeys (n = 5) received either basal feed (CON), fumonisin-contaminated feed (15 mg/kg FB₁+FB₂; FB) or fumonisin-contaminated feed supplemented with FUMzyme (15 U/kg; FB+FUMzyme) for 14 days ad libitum. Addition of FUMzyme resulted in significantly decreased levels of FB₁ in excreta, whereas HFB₁ concentrations were significantly increased. Compared to the FB group (0.24 ± 0.02), the mean serum sphinganine-to-sphingosine (Sa/So) ratio was significantly reduced in the FB+FUMzyme group (0.19 ± 0.02), thus resembling values of the CON group (0.16 ± 0.02). Similarly, exposure of piglets (n = 10) to 2 mg/kg FB₁+FB₂ for 42 days caused significantly elevated serum Sa/So ratios (0.39 ± 0.15) compared to the CON group (0.14 ± 0.01). Supplementation with FUMzyme (60 U/kg) resulted in gastrointestinal degradation of FB₁ and unaffected Sa/So ratios (0.16 ± 0.02). Thus, the carboxylesterase FumD represents an effective strategy to detoxify FB₁ in the digestive tract of turkeys and pigs.

The mycotoxin zearalenone (ZEN) is a frequent contaminant of animal feed and is well known for its estrogenic effects in animals. Cattle are considered less sensitive to ZEN than pigs. However, ZEN has previously been shown to be converted to the highly estrogenic metabolite α-zearalenol (α-ZEL) in rumen fluid in vitro. Here, we investigate the metabolism of ZEN in the reticulorumen of dairy cows. To this end, rumen-fistulated non-lactating Holstein Friesian cows (n = 4) received a one-time oral dose of ZEN (5 mg ZEN in 500 g concentrate feed) and the concentrations of ZEN and ZEN metabolites were measured in free rumen liquid from three reticulorumen locations (reticulum, ventral sac and dorsal mat layer) during a 34-h period. In all three locations, α-ZEL was the predominant ZEN metabolite and β-zearalenol (β-ZEL) was detected in lower concentrations. ZEN, α-ZEL and β-ZEL were eliminated from the ventral sac and reticulum within 34 h, yet low concentrations of ZEN and α-ZEL were still detected in the dorsal mat 34 h after ZEN administration. In a second step, we investigated the efficacy of the enzyme zearalenone hydrolase ZenA (EC 3.1.1.-, commercial name ZENzyme^®, BIOMIN Holding GmbH, Getzersdorf, Austria) to degrade ZEN to the non-estrogenic metabolite hydrolyzed zearalenone (HZEN) in the reticulorumen in vitro and in vivo. ZenA showed a high ZEN-degrading activity in rumen fluid in vitro. When ZenA was added to ZEN-contaminated concentrate fed to rumen-fistulated cows (n = 4), concentrations of ZEN, α-ZEL and β-ZEL were significantly reduced in all three reticulorumen compartments compared to administration of ZEN-contaminated concentrate without ZenA. Upon ZenA administration, degradation products HZEN and decarboxylated HZEN were detected in the reticulorumen. In conclusion, endogenous metabolization of ZEN in the reticulorumen increases its estrogenic potency due to the formation of α-ZEL. Our results suggest that application of zearalenone hydrolase ZenA as a feed additive may be a promising strategy to counteract estrogenic effects of ZEN in cattle.

Mycotoxins deoxynivalenol (DON) and zearalenone (ZEN) can negatively affect pig health. However, little is known about their effects on boar semen. We assessed the individual and combined effects of DON and ZEN on boar semen in vitro. In a pretrial, we determined the minimum dose (MiD) of each mycotoxin that induces a significant alteration of sperm progressive motility, as investigated using computer-assisted semen analysis (CASA). In the main trial, the individual and combined effects of each mycotoxin’s MiD on sperm motility and kinetics (CASA analysis), morphology (SpermBlue staining), viability (calcein-propidium iodide staining), membrane functional status (hypoosmotic swelling test), and chromatin integrity (acridine orange staining) were analyzed. Pretrial results suggested a MiD of 50.6 μM and 62.8 μM for DON and ZEN, respectively. In the main trial, DON and ZEN administered at MiD significantly affected CASA parameters (e.g., increase of immotile spermatozoa, reduction of progressive motile spermatozoa), decreased sperm viability, and affected sperm morphology (head abnormalities) and membrane functional status. DON and ZEN showed less than additive effects on most parameters tested and a synergistic effect on viability and on two CASA parameters. In conclusion, DON and ZEN showed individual and combined toxic effects on boar semen in vitro.

The mycotoxin fumonisin B1 (FB1) is a frequent contaminant of feed. It causes a disruption of sphingolipid metabolism and pulmonary, hepatic, and immunological lesions in pigs depending on the exposure scenario. One sensitive biomarker for FB1 exposure is the sphinganine (Sa) to sphingosine (So) ratio in blood. The fumonisin esterase FumD, which can be used as a feed additive, converts FB1 into the much less toxic metabolite hydrolyzed FB1 (HFB1). We conducted a single-dose study with barrows allocated to one of five treatments: (1) control (feed, 0.9% NaCl intravenously iv), (2) 139 nmol FB1 or (3) HFB1/kg BW iv, (4) 3425 nmol FB1/kg BW orally (po), or (5) 3321 nmol FB1/kg BW and 240 U FumD/kg feed po. The Sa/So ratio of iv and po FB1 administered groups was significantly elevated in blood and Liquor cerebrospinalis, but no fumonisin-associated differences were reflected in other endpoints. Neither clinical lung affections nor histopathological pulmonary lesions were detected in either group, while some parameters of hematology and clinical biochemistry showed a treatment–time interaction. FumD application resulted in Sa/So ratios comparable to the control, indicating that the enzymatic treatment was effectively preventing the fumonisin-induced disruption of sphingolipid metabolism.

The impact of the Fusarium-derived metabolites beauvericin, enniatin B and B1 (EB) alone or in combination with deoxynivalenol (DON) was investigated in 28-29 days old weaning piglets over a time period of 14 days. The co-application of EB and DON (EB + DON) led to a significant decrease in the weight gain of the animals. Liver enzyme activities in plasma were significantly decreased at day 14 in piglets receiving the EB + DON-containing diet compared to piglets receiving the control diet. All mycotoxin-contaminated diets led to moderate to severe histological lesions in the jejunum, the liver and lymph nodes. Shotgun metagenomics revealed a significant effect of EB-application on the gut microbiota. Our results provide novel insights into the harmful impact of emerging mycotoxins alone or with DON on the performance, gut health and immunological parameters in pigs.

Ruminal microbiota of cattle are not able to detoxify all mycotoxins. In addition, detoxification can be hampered by adverse ruminal conditions (e.g., low ruminal pH). Hence, in the cattle husbandry, mycotoxin binders and modifiers could be used to prevent animal exposure to mycotoxins. In this study, an in vitro rumen model, including feed matrix, was established as first screening tool to test the efficacy of five products claiming to detoxify mycotoxins. The detoxifiers had different modes of action: (a) binding (three products); (b) enzymatic detoxification of zearalenone (ZEN; one product, ZenA); and (c) bacterial transformation of trichothecenes (one product, BBSH 797). For the mycotoxin binders, the binding to the mycotoxins enniatin B (ENN B), roquefortine C (ROQ-C), mycophenolic acid (MPA), deoxynivalenol (DON), nivalenol (NIV), and zearalenone (ZEN) were tested at a dose recommended by the manufacturers. The in vitro model demonstrated that all binders adsorbed ENN B to a certain extent, while only one of the binders also partially adsorbed ROQ-C. The binders did not change the concentrations of the other mycotoxins in the ruminal fluid. The enzyme ZenA detoxified ZEN very quickly and prevented the formation of the more toxic metabolite α-zearalenol (α-ZEL), both at normal (6.8) and low ruminal pH (5.8). The addition of BBSH 797 enhanced detoxification of DON and NIV, both at normal and low ruminal pH. The in vitro rumen model demonstrated that the addition of ZenA seems to be a very promising strategy to prevent estrogenic effects of ZEN contaminated feed, and BBSH 797 is efficient in the detoxification of trichothecenes.